This document summarizes a lecture on welded connection design between two C10x30 steel channel sections. It provides the design parameters for the connection including a service dead load of 80 kips, service live load of 300 kips, A36 steel type, and E60X electrode type. It then shows the design calculation to determine the required weld size of 49 inches total, with 10 inches along the web and 19.5 inches along each flange. The next topic is listed as a numerical problem on designing tension members.
This document summarizes a lecture on welded connection design between two C10x30 steel channel sections. It provides the design parameters for the connection including a service dead load of 80 kips, service live load of 300 kips, A36 steel type, and E60X electrode type. It then shows the design calculation to determine the required weld size of 49 inches total, with 10 inches along the web and 19.5 inches along each flange. The next topic is listed as a numerical problem on designing tension members.
This document summarizes a lecture on welded connection design between two C10x30 steel channel sections. It provides the design parameters for the connection including a service dead load of 80 kips, service live load of 300 kips, A36 steel type, and E60X electrode type. It then shows the design calculation to determine the required weld size of 49 inches total, with 10 inches along the web and 19.5 inches along each flange. The next topic is listed as a numerical problem on designing tension members.
WELDED CONNECTION DESIGN DESIGN A WELDED CONNECTION FOR TWO STEEL CHANNEL SECTIONS C10X30 FOR SERVICE DEAD LOAD OF 80 KIPS & SERVICE LIVE LOAD OF 300 KIPS WITH THE FOLLOWING DATA: MEMBER’S TYPE = CHANNEL SECTIONS SECTION DEPTH = 10” STEEL TYPE = A 36 ELECTRODE TYPE = E 60X WELD SIZE = MINIMUM RECOMMENDED LOAD TYPE = TENSILE FORCE
ENGR. ADIL SHAHZAD (SUIT PESHAWAR) 3
ENGR. ADIL SHAHZAD (SUIT PESHAWAR) 4 ENGR. ADIL SHAHZAD (SUIT PESHAWAR) 5 ENGR. ADIL SHAHZAD (SUIT PESHAWAR) 6 ENGR. ADIL SHAHZAD (SUIT PESHAWAR) 7 Unit Weld Capacity is given by: q=0.75xTxFv = 0.75x0.221x36 =5.97 kips
Total length = 288 / 5.97
= 48.3 in /channel
Provide 49 in weld /channel
Distribution of weld = 10 in along web + 19.5 in along flange sides. ENGR. ADIL SHAHZAD (SUIT PESHAWAR) 8 ENGR. ADIL SHAHZAD (SUIT PESHAWAR) 9 NEXT TOPIC: