Professional Documents
Culture Documents
Programming Parameters
Programming Parameters
Shutdown SIS
Previous Screen
Troubleshooting
G3500 Engines
Media Number -SENR6413-08 Publication Date -01/06/2008 Date Updated -05/06/2008
i01998962
Programming Parameters
SMCS - 1901
Programming Parameters
The Electronic Ignition System's control module (EIS control module) and the Electronic Control
Module (ECM) have several parameters that can be programmed for the individual installation. The
Digital Diagnostic Tool (DDT) or the Caterpillar Electronic Technician (Cat ET) is necessary for
programming the parameters.
The parameters are grouped into the following three menus on the DDT: "CUSTOMER SPECIFIED
PARAMETERS (C.S.P.)", "TIMING" and "O2 TEST". Refer to Table 1 for the names of each
parameter.
Refer to Systems Operation/Testing and Adjusting, "Electronic Control System Parameters" for the
descriptions of the parameters.
Table 1
Programmable Parameters for the Electronic Ignition System (EIS) and the Air/Fuel Ratio
Control (AFRC)
DDT Cat ET
"C.S.P (CUSTOMER SPECIFIED PARAMETERS)"
AFRC "DES FULL LOAD 02" "Desired Oxygen at Full Load"
AFRC "GOV P-GAIN" "Governor Gain Factor"
AFRC "GOV STAB" "Governor Stability Factor"
AFRC "GOV COMP" "Governor Compensation Factor"
AFRC "AUX 1 GOV GAIN" "Auxiliary Proportional Governor Gain 1"
https://sisweb.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/s... 21/09/2009
G3516 Generator Set CSZ00001-UP(SEBP3374 - 29) - Document Structure Page 2 of 3
If a module is replaced, the appropriate parameters must be copied from the old module. The settings
can be recorded on paper and then programmed into the new module. Alternatively, this can be done
with the "Copy Configuration" feature of the Caterpillar Electronic Technician (ET).
NOTICE
Changing the parameters during engine operation can cause the engine
to operate erratically. This can cause engine damage.
Unless you are otherwise instructed, only change the settings of the
parameters when the engine is STOPPED.
Copyright 1993 - 2009 Caterpillar Inc. Mon Sep 21 11:51:20 UTC+0700 2009
All Rights Reserved.
https://sisweb.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/s... 21/09/2009
G3516 Generator Set CSZ00001-UP(SEBP3374 - 29) - Document Structure Page 3 of 3
https://sisweb.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/s... 21/09/2009