Professional Documents
Culture Documents
Revision OBJECTIVES
Revision OBJECTIVES
1. The relative amount of a particular phase present in the pore space is called
(A) permeability
(B) porosity
(C) saturation
2. The viscosity of crude oil measured at a pressure above bubble point and system temperature condition is
known as
3. Which of the following is the least likely source for water which encroaches into a reservoir as pressure
declines?
(A) water coming out of solution from the oil as the pressure drops
4. What type of reservoir drive maintains a constant reservoir pressure most of the production life?
5. Which of the following curve determine the economic limit for a well?
6. A change in permeability value is observed while determining permeability with gases at different pressure.
This is known as
(A) Viscosity effect
7. In PVT behavior, solution gas liberated from the oil sample remains in contact with the oil surface to
establish the equilibrium. The process is known as
(A) future water production, optimal infill well location, results of fracture stimulation treatments
(C) unique reservoir description, optimal enhanced recovery method, good matches of reservoir history
(D) optimal well spacing in reservoirs, coning characteristics of wells, and optimal flood patterns in
improved recovery projects
10. A commercial oil reservoir has recently been discovered. If the oil reservoir is producing at pressures above
the bubble point pressure, the factor in material balance calculations that is far more important than if the
reservoir were producing below the bubble point pressure is
11. Type of drive when the hydrocarbons are enclosed by a porous media and the only energy comes from the
pressure is known as
12. What type of reservoir drive has a low initial gas/oil ratio increasing to a max near the end of production?
13. ______ is normally referred for those oils produced from deep reservoirs which occur in the reservoir as
liquid and exhibit a large degree of shrinkage when brought to the surface.
14. The maximum water saturation at which the water phase will remain immobile is known as
15. The maximum water saturation at which the water phase will remain immobile is known as
(A) wettability
(B) saturation
(C) porosity
(D) tortuosity
17. Which of the following parameters influence oil viscosity?
(B) temperature
(C) pressure
18. What type of reservoir drive maintains a constant reservoir pressure most of the production life?
20. Which of the following is the basis for the classification of reservoir aquifer systems?
21. Which of the following is the measure of storage capacity that is capable of holding fluids?
(B) permeability
(C) porosity
22. The viscosity of crude oil measured at a pressure above bubble point and system temperature condition is
known as
(C) suck in the non-wetting fluid phase and to repel the wetting phase
(D) suck in the wetting fluid phase and to repel the non wetting phase
24. Which of the following is the least likely characteristic of a reservoir fluid?
(A) superfluid
(D) gas
25. Which reservoir drive mechanism has the highest recovery factor?
(A) wettability
(B) drainage
(C) imbibition
(C) square in
(D) millidarcy
(A) 12%
(B) 22%
(C) 26%
(D) 32%
30. What is the boundary water called that moves in a water drive reservoir?
31. Name the type of reservoir drive that has a constant oil/gas ratio most of the producing time increasing near
the end of production?
(A) compositional
(B) thermal
33. Type of drive when the hydrocarbons are overburden with stress making the reservoir pressure is reduced is
known as
(A) aquifer
35. The percentage of interconnected space with respect to the bulk volume is called