Professional Documents
Culture Documents
JOB SHEET
1. CX-Programmer
TOOLS /
2. PLC Omron CJ1M CPU21
EQUIPMENTS /
3. Lamp
MATERIALS :
4. Switch
5. Touch Panel
1
Lampiran DPP C2(c)-13
DRAWING AND
DATA :
INSTRUCTION :
PROCEDURE
KEY
POIN STEP
T
Figure 1
2
Lampiran DPP C2(c)-13
PROCEDURE
KEY
POIN STEP
T
Figure 2
Figure 3
3
Lampiran DPP C2(c)-13
PROCEDURE
KEY
POIN STEP
T
Figure 4
Figure 5
4
Lampiran DPP C2(c)-13
PROCEDURE
KEY
POIN STEP
T
Figure 6
(f) Draw on the touch panel as in figure 7 using PB button, bit lamp button
and command button.
5
Lampiran DPP C2(c)-13
PROCEDURE
KEY
POIN STEP
T
Figure 7
(g) Double click the button that already been draw on touch panel and set
the address so it will be link to the ladder diagram in CX-programmer
such as in figure 8
6
Lampiran DPP C2(c)-13
PROCEDURE
KEY
POIN STEP
T
Figure 8
(h) Set the address for PB and Bit lamp, make sure it is same with
address in ladder diagram. For command button, the setting is in
figure 9 which means if the button presses than it will go to page0001.
7
Lampiran DPP C2(c)-13
PROCEDURE
KEY
POIN STEP
T
Figure 9
(i) To do labeling for each item, go to label bar when double click the item
and write the name as in figure 10.
8
Lampiran DPP C2(c)-13
PROCEDURE
KEY
POIN STEP
T
Figure 10
(j) To add a new screen, right click on screen category and add screen
as shown in figure 11.
9
Lampiran DPP C2(c)-13
PROCEDURE
KEY
POIN STEP
T
Figure 11
10
Lampiran DPP C2(c)-13
PROCEDURE
KEY
POIN STEP
T
Figure 12
(l) Test the touch panel by using PLC-PT Integrated Simulation as shown
in figure 13 and start the simulation.
Figure 13
(m) New window will pop-up such as figure 14 and try click any
button to see if the touch panel working.
Figure 14
11
Lampiran DPP C2(c)-13
PROCEDURE
KEY
POIN STEP
T
Figure 15
RESULT :
QUESTION/DISCUSSION :
CONCLUSION :
12