Department: Time In________________Time out__________________
Initial Appropriate Box
Defect Found Defect Found. Not Serviceable Step Task and Repaired Safe to Operate Applicable 1 Drain Engine Oil and Refill 2 Replace Engine Oil Filter 3 Check air intake filter (Replace as required) Check air intake system for loose clamps, damaged components (Replace 4 as required) 5 Check condition and tension of fan belts (replace adjust as required) 6 Check coolant level (adjust as required) Take care, hot coolant! 7 Check radiator for excessive debris build up (clean as required) 8 Check brake fluid level (adjust as required) 9 Check power steering fluid level (adjust as required) 10 Check clutch fluid level (adjust as required) 11 Check windscreen washer fluid level (adjust as required) 12 Check battery electrolyte level (adjust as required) 13 Clean top of battery and terminals and check security 14 Check gearbox oil level (adjust as required) 15 Check transfer case oil level (adjust as required) 16 Check front differential oil level (adjust as required) 17 Check rear differential oil level (adjust as required) 18 Check gearbox mount condition 19 Check engine mounts condition 20 Check tray mounts and tray (if applicable) 21 Check condition of front and rear suspension components 22 Check chassis for cracking or damage 23 Check all door handles operate correctly 24 Check all wheel bearings and knuckle joints for excessive movement Check ball joint rubber boots and seals for deterioration. Any damaged or deteriorated items found need to be removed and replaced. Components 25 they are fitted to need to be inspected for damage, corrosion and wear, then greased and reassembled Check steering ball joints for wear, damage or movement. (Note: if all 26 adjustment range is used then replace associated components as required) 27 Grease steering linkages 28 Grease steering knuckle joints 29 Grease ALL driveshaft splines and universal joints (hand gun only) 30 Lubricate all door hinges and locking mechanisms 31 Check whether seat belts are installed and their buckles are holding Check tyre pressures Pos 1 Pos 2 Pos 3 Pos 4 Actual Adjusted 32 Affix next service due sticker to windscreen 33 Vehicle to be returned clean Comments: