Professional Documents
Culture Documents
TASK 32−51−31−000−801
1. Removal of the Electronic Control Module (ECM)
NOTE: Before you remove the ECM, refer to the advisory wire (AW600−32−2390).
A. Reference Information
REFERENCE DESIGNATION
REFERENCE DESIGNATION
NOTE: Refer to the Illustrated Tool and Equipment Manual to make sure that you use
the correct equipment configuration.
C. Job Set−Up
EFFECTIVITY: ALL
D. Procedure
(1) Remove the cable connector plugs (3) and (4) from the Electronic Control Module
(ECM) (1) or (6).
(2) Install the protective covers on the connector plugs (3) and (4).
(3) Remove the screws (2) and the washers (5) that attach the ECM (1) or (6) to the
bulkhead.
(4) Remove the ECM (1) or (6) from the avionics compartment.
EFFECTIVITY: ALL
5
2
FS235.00
5
2 3
6 3
DMM3251314_001
EFFECTIVITY: ALL
TASK 32−51−31−400−801
2. Installation of the Electronic Control Module (ECM)
A. Reference Information
REFERENCE DESIGNATION
B. Parts
2 Screw 4 32−51−13−01−010
5 Washer 4 32−51−13−01−011
C. Job Set−Up
(1) Make sure the aircraft is in the same configuration as in the removal task.
D. Procedure
(1) Install the Electronic Control Module ECM (1) or (6) on the bulkhead with the
screws (2) and the washers (5).
(2) Remove the plastic covers and attach the cable connector plugs (3) and (4) to the
ECM (1) or (6).
(3) Remove the tags and close the circuit breakers that follow:
(4) On aircraft with ECM model number 7040−13/15, do an operational test of the nose
wheel steering electronic control module (ECM) (TASK 32−51−31−710−801).
EFFECTIVITY: ALL
E. Close Out
(1) Remove all tools, equipment, and unwanted materials from the work area.
EFFECTIVITY: ALL