Professional Documents
Culture Documents
Engineering
ELECTRICAL ENGINEERING & CONTRACTORS
Project : CRM 2 Document. No. MCE/HSE/SOP/01
PURPOSE: The purpose of this standard is to prevent injury and property damage when
conducting work at height.
SCOPE: This procedure covers cable laying, manual material handling,
welding, grinding, height work, and precaution to be taken during cable laying,
cable tray erection work.
Manpower:
Helper
welder
Electrician
Fitter
Supervisor
Safety officer
Work in charge
POTENTIAL RISKS:
Personal falling
Falling material
Collapse of scaffolding
Fragile surface
Overbalancing or losing grip
Unprotected opening
Sharp Edges, Pinch Points
Work at height
Hot atmosphere
SPECIAL SAFETY REQUIREMENTS:
Fall prevention device, i.e. fall arrest system with harness and
anchor points.
Rotating or sharing between internal and external work.
Worker should wear clothing that over all covers as much skin as
possible
Method 1:
Welding of angles for the purpose of jointing/fabricating the
angles to make type supports to support cable tray
Grinding for welded angles for the purpose of removal of
additional welding flex materials and sharp edges of angles
Fixing of fabricated type angles in the installation of cable tray
Painting the angles/channels with final coat
Working of heights when installing cable tray
CHECK LIST:
Work at height Checklist
Scaffolding erection/modification Checklist
Lifting tools and tackles Checklist
Vehicle Checklist
Welding machine Checklist
Grinding machine Checklist
Cutting machine Checklist
TBT conducted as per job
Workman training conducted sheet