DEFINITION SURFACE PREPARATION Novo Go Alkyd matt is matt synthetic enamel • The surface of the substrate should be paint, based on Alkyd resin, and other selected cleaned from oil, grease, dirt, and loose pigments and fillers. particles. ADVANTAGES • The surface should be smoothed well by o Easy to apply. suitable putty and blasted to be smooth. o High coverage because of the use of finely • The substrate should be primed or coated grounded and high-quality pigments. with suitable under coat then left to dry and o After drying, it produces matt elastic smoothed down with sand paper. homogenous film that is well adhered to the • Steel surface should be plastered and primed substrate and resisted abrasion and by Novo Prime R scratching. • Mix well the contents that will be used. USES • One or two coats of Novo Go alkyd -matt ▪ Can be applied on synthetic primer or are recommended to apply. undercoat or on both...also. • Can be applied by brush, roller or spraying ▪ On wooden, metallic and plastered surface. gun. ▪ Can be used as high-quality undercoat • Can be thinned by Novo sol M 8 if needed. before application top coat of glossy alkyd • Clean tools by Novo sol T9 or Novo sol M 8 paint like Novo Go Alkyd Glossy COVERAGE PHYSICAL PROPERTIES @ 25 Cº 4- 6 m2 / kg / 75-micron coat. DISCRIPTION VALUE (Depending on the surface condition and type) Color white and colored STORAGE CONDITIONS Density (1.6 ±0.05) kg / L • Best stored at room temperature in dry Viscosity 38 ± 5 poise conditions. • Avoid humidity, cold freezing conditions Solid content (by WT.) (80 ±2) % and off concrete floors. Solid content (by Vol.) (50 ±2) % • Do not store in direct sunlight. (10 -30) Cº Surface dry 1 hr. PRECAUTIONS & SAFETY Hard dry 24 hr. o Wear protective clothes, gloves, glasses Full cure 7 days and face protection. Thinner Sol M 8 o Application should be carried out in well ventilate place Shelf life 12 months in suitable storage conditions o For skin contact, remove it with suitable cream followed by soap and water cleaning. o Don’t eat or smoke during use.