Novo GO Alkyd Glossy is a high gloss synthetic enamel paint based on alkyd resin and selected pigments. It provides a homogenous, glossy film that adheres well to substrates and is resistant to abrasion. It can be applied to wooden, metallic, and plastered surfaces using a brush, roller, or spray gun. Proper surface preparation including cleaning, smoothing, and priming is required. The paint has a high coverage rate of 9-10 square meters per liter and requires precautions such as protective clothing and ventilation during application.
Novo GO Alkyd Glossy is a high gloss synthetic enamel paint based on alkyd resin and selected pigments. It provides a homogenous, glossy film that adheres well to substrates and is resistant to abrasion. It can be applied to wooden, metallic, and plastered surfaces using a brush, roller, or spray gun. Proper surface preparation including cleaning, smoothing, and priming is required. The paint has a high coverage rate of 9-10 square meters per liter and requires precautions such as protective clothing and ventilation during application.
Novo GO Alkyd Glossy is a high gloss synthetic enamel paint based on alkyd resin and selected pigments. It provides a homogenous, glossy film that adheres well to substrates and is resistant to abrasion. It can be applied to wooden, metallic, and plastered surfaces using a brush, roller, or spray gun. Proper surface preparation including cleaning, smoothing, and priming is required. The paint has a high coverage rate of 9-10 square meters per liter and requires precautions such as protective clothing and ventilation during application.
DEFINITION SURFACE PREPARATION Novo GO is high glossy synthetic enamel paint, • The surface of the substrate should be based on Alkyd resin and other selected pigments cleaned from oil, grease, dirt, and loose and fillers. particles. • The surface should be smoothed well by ADVANTAGES suitable putty and blasted to be smooth. 1. Acquire a homogenous consistency by • The substrate should be primed or coated manual mixing. with suitable under coat (Novo GO Alkyd 2. Easy to apply. Matt) then left to dry and smoothed down with sand paper. 3. High coverage because of finely grounded • Steel surface should be plastered and primed using and high-quality pigments. by Novo Prime R. 4. After drying, it produces glossy elastic • Mix well the contents that will be used. homogenous film that is well adhered to • One or two coats of Novo GO are the substrate and resisted abrasion and recommended to apply. scratching. • Can be applied by brush, roller or spraying USES gun. ▪ Can be applied on synthetic primer, • Can be thinned by Novo sol M 8 if needed. undercoat or on both also. • Clean tools after finishing by Novo sol T 9 ▪ On wooden, metallic and plastered surface. or Novo sol M 8
PHYSICAL PROPERTIES @ 25 Cº COVERAGE
• 9-10 m2 / L /50-micron coat (depending DISCRIPTION VALUE on the surface condition and type) Color white and colored STORAGE CONDITIONS Density (1.15 ±0.02) gm. / cm 3 • Best stored at room temperature in dry Viscosity 25 ± 5 poise conditions. • Avoid humidity, cold freezing Solid content (by WT.) (60 ±2) % conditions and off concrete floors. Solid content (by Vol.) (40 ±2) % • Do not store in direct sunlight. (10 -30) Cº Surface dry 6 hrs. PRECAUTIONS & SAFETY o Wear protective clothes, gloves, glasses Hard dry 24 hrs. and face protection. Full cure 7 days o Application should be carried out in Thinner Sol M 8 well ventilate place. Shelf life 12 months ( in suitable o For skin contact, remove it with suitable storage conditions) cream followed by soap and water cleaning. o Don’t eat or smoke during use.