Professional Documents
Culture Documents
When you are wiring motors, check that the speed controller is configured for
output with the correct voltage for the connection type. When a speed controller is
used, it is normally possible to program the exact voltage specified on the Name
plate of the motor as the output voltage. You should also set any other
parameters on the Name plate into the speed controller configuration.
Note that a speed controller’s output voltage will not exceed its input supply
voltage.
A single phase input speed controller cannot produce the line voltage for a Y or
Star connection. It should be wired as a YY or Delta connection.
Six-pin motors are used on sorting machines in New Zealand, Australia, and
Europe. On six-pin motors, the low voltage connection is called Delta and the high
voltage connection is called Star. Most Compac motors should be wired using a
Star connection. The exception is the main drive motor since it is usually larger
than 2.5 Kw and requires a higher line voltage than is available at most
installations. Therefore it is normally wired in Delta. If you are unsure which
connection to use, wire the motor using the Star connection. If this is not correct,
the motor will not burn out immediately (though it will be under-powered, and draw
current in excess of the name plate rating at no load. This may trip out on
overload.)
Nine-pin motors are used on sorting machines in the United States. On nine-pin
motors, the low voltage connection is called YY and the high-voltage connection
is called Y. Most Compac motors should be wired using the Y connection. The
exception is the main drive motor, normally wired at YY. If you are unsure which
connection to use, wire the motor using the Y connection. If this is not correct, the
motor will not burn out immediately, as noted above.