Professional Documents
Culture Documents
Trapped floor gully Standard 110mm PVCu soil pipe can be used to provide an extension
piece between the trap body and grating to allow for different floor
The trapped floor gully is suitable for use as a shower outlet in constructions. Although primarily designed for use with ceramic floor
bathrooms or as a floor gully for washdown areas in domestic, public tiles, sheet floor applications can be accommodated provided that the
and commercial buildings. Available with 50 and 82mm size solvent floor surface is finished to the appropriate height and the joint made
weld outlets for connection to MUPVC, ABS and PVCu pipework to with a water resistant sealant.
BS 5255:1989 and BS 4515:1983 respectively, the 150mm square The main body of the trap and the base are supplied loose to allow
PVCu grating is designed to withstand normal foot traffic in the bottom part of the gully to be trimmed on-site prior to
accordance with the surface load requirements as defined in BS EN installation. As a result, the depth of water seal can be varied to suit
1253-1. different situations before the base is fitted by solvent weld jointing.
Each size of gully has three solvent weld waste inlet connections, two Also incorporated in the trap is a push-fit access plug which allows
40mm an opposing sides and a 50mm rear connection which accept outlet pipework to be rodded if necessary.
MUPVC or ABS small diameter sanitary pipework to BS 5255:1989.
110mm
SGG3
extension
grating
110mm pipe
pipe
50mm
pipe
SFG42AS
floor gully
SWS42
boss pipe
Finished Floor
and Shower outlet range Level
Screed
Trapped Body
54