Professional Documents
Culture Documents
Ejector tool
7336-2W44
2015-02-04
Fig. 54209
Tool components Ejector punch, Alignment ring Ejector die, Ejector die,
complete Size 2 round square
7336-U467 072062 7336-16892 7336-17256
Tab. 1
2. Applications
The ejector tool enables quick and reliable ejection of laser cut
parts and scrap in Microjoint technique. This involves placing the
ejector punch on the microjoint, cutting the part off in one single
stroke and ejecting it with the die. The maximum part size that can
be ejected is limited by the die size (square 50.1 mm and round
70.1 mm).
Fig. 54210
Processing example
1 2 3
Fig. 54211
Loading information The three punch inserts that are not required must be removed
before using the ejector tool.
Die 55.1
Punch insert ∅ 8 (position 1)
Punch insert ∅ 3 (position 3)
Fig. 54212
Die ∅ 70.1
Punch insert ∅ 8 (position 2)
Punch insert ∅ 3 (position 4)
Fig. 54213
Tool length The tool length must be entered in the tool data of the control. It is
measured from the top of the alignment ring to the underside of the
punch.
A length of 34.3 is valid for this tool.
Stroke types
The following stroke types can be selected for optimum use of the
tool:
Punch without support position.
TruPunch 5000: The displayed value for the stroke type is 1.
Necessary options
Some tools can only be used with a special machine option e.g.
"Active die".
For this tool, the applicable value is 0 = none.
4. TruTops
Tool type 9 The ejector tool is handled by TruTops as a special tool with tool
type 9 and is supported starting with the following versions.
TruTops Version
TruTops V1.0
TruTops Boost V1.0
Tab. 3
Fig. 54214