This document provides instructions for analyzing a two storey residential building using STAAD software. It describes how to create groups for one-way and two-way slabs, define structural sections, assign sections, define reference dead loads, add primary load cases including seismic and live loads, run the analysis, and design the beams and columns for concrete including defining reinforcement parameters. The output of the STAAD analysis is to be sent to the specified email address.
This document provides instructions for analyzing a two storey residential building using STAAD software. It describes how to create groups for one-way and two-way slabs, define structural sections, assign sections, define reference dead loads, add primary load cases including seismic and live loads, run the analysis, and design the beams and columns for concrete including defining reinforcement parameters. The output of the STAAD analysis is to be sent to the specified email address.
This document provides instructions for analyzing a two storey residential building using STAAD software. It describes how to create groups for one-way and two-way slabs, define structural sections, assign sections, define reference dead loads, add primary load cases including seismic and live loads, run the analysis, and design the beams and columns for concrete including defining reinforcement parameters. The output of the STAAD analysis is to be sent to the specified email address.
storey residential using staad Create two groups for 1 way and 2-way slab Create two groups for 1 way and 2-way slab Create two groups for 1 way and 2-way slab DEFINE SECTIONS • COMMANDS-MEMBER PROPERTY-PRISMATIC- RECTANGLE • INPUT THE FF SECTIONS DEFINE SECTIONS • ASSIGN THE SECTIONS DEFINE SECTIONS • ASSIGN THE SECTIONS DEFINE SECTIONS • ASSIGN THE SECTIONS DEFINE SECTIONS • ASSIGN THE SECTIONS DEFINE SECTIONS • ASSIGN THE SECTIONS DEFINE LOAD • DEFINE REFERENCE DEAD LOAD DEFINE LOAD • DEFINE REFERENCE DEAD LOAD DEFINE LOAD • DEFINE REFERENCE DEAD LOAD DEFINE LOAD • DEFINE REFERENCE DEAD LOAD DEFINE LOAD • DEFINE REFERENCE DEAD LOAD DEFINE LOAD • DEFINE REFERENCE DEAD LOAD DEFINE LOAD • DEFINE REFERENCE DEAD LOAD DEFINE LOAD • DEFINE REFERENCE DEAD LOAD DEFINE LOAD • DEFINE REFERENCE DEAD LOAD DEFINE LOAD • DEFINE REFERENCE DEAD LOAD DEFINE LOAD • DEFINE REFERENCE DEAD LOAD DEFINE LOAD • ADD PRIMARY LOAD CASES DEFINE LOAD • FOR EX, ADD SEISMIC LOAD IN X DIRECTION AND Z DIRECTION FOR EZ DEFINE LOAD • FOR DL, ADD REPEAT LOAD->REFERENCE LOAD->SELECT THE REFERENCE DEAD LOAD DEFINE LOAD • FOR LL, ADD FLOOR LOADS, SEE PRIOR STEPS, AND MEMBER LOAD FOR ROOF BEAMS DEFINE LOAD • DEFINE LOAD CASES DEFINE LOAD • COMMANDS->ANALYSIS->PERFORM ANALYSIS-> OKAY • ANALYZE->RUN ANALYSIS • PROCEED IF NO ERROR DEFINE LOAD • COMMANDS->ANALYSIS->PERFORM ANALYSIS-> OKAY • ANALYZE->RUN ANALYSIS • PROCEED IF NO ERROR • COMMANDS->DESIGN->CONCRETE DESIGN • ON CONCRETE DESIGN WINDOW, DEFINE PARAMETERS->ADD CLB,CLS,CLT-> ASSIGN TO ALL DEFINE LOAD • DEFINE PARAMETERS -> MINMAIN->16 -> ADD->ASSIGN TO ALL • DEFINE PARAMETERS -> MAXMAIN -> 20 -> ADD -> ASSIGN TO ALL • DEFINE PARAMETERS -> FC -> 20700 -> ADD -> ASSIGN TO ALL • DEFINE PARAMETERS -> FYMAIN -> 275000 -> ADD -> ASSIGN TO ALL DEFINE LOAD • DEFINE PARAMETERS -> REINF -> (0) TIED COLUMN -> ADD -> ASSIGN TO ALL COLUMNS • DEFINE PARAMETERS -> RHOMN -> 0.008 -> ADD -> ASSIGN TO ALL COLUMNS • COMMANDS ON DESIGN WINDOW -> DESIGN BEAM -> ADD -> ASSIGN TO ALL BEAMS • COMMANDS ON DESIGN WINDOW -> DESIGN COLUMN -> ADD -> ASSIGN TO ALL COLUMNS • RUN ANALYSIS ALL OUTPUT SHALL BE SENT TO reirobinroland.tumambing@ub.edu.ph