You are on page 1of 10

AURCO safety Training Program

Topic : Fire Safety

Location of training: AURCO TRAINING ROOM

Prepared BY: SHABBIR HUSSAIN (HSE Officer)


WORKPLACE HAZARDS & SOLUTIONS

FIRE
A composition of Fuel, oxygen and heat is set out as Fire

 FIRE is a big hazard at


construction site, it kills and
injuries people, destroys
property and seriously
disrupt may and
production
construction process. the

 Practical steps can be taken to


prevent and minimize the risk of
fire in the site.
WORKPLACE HAZARDS & SOLUTIONS

FIRE - cause
Poor safety practices cause FIRE

1. Hot work– Welding, Cutting etc.

2. Overheating of machineries

3. Electric short circuit and


overloading

4. Improper storage of Flammable


& Combustible liquids

5. Poor Housekeeping

6. Careless Smoking
WORKPLACE HAZARDS & SOLUTIONS

FIRE - Prevention
1. Adequate Fire Safety training
2. Effective PTW for all hot work
3. Good maintenance of electrical equipments
4. Restriction of smoking.
5. Sufficient Fire Points
6. Good housekeeping, Proper storage and clean up of combustible
and flammable liquids
7. Regular FIRE Safety inspection in site and camps.

EVERY EMPLOYEE & VISITORS MUST KNOW

The local
The department / Area Locations of The location of FIRE The location
Emergency
emergency procedures and extinguishers in your ALRAM & How to raise Contacts – FIRE of
evacuation routes / Fire Exit. area and How to use the ALRAM 997, Police-999, Assembly
Ambulance - 998 point
WORKPLACE HAZARDS & SOLUTIONS

FIRE - Fighting
A Class Fire (solid ) - Free
burning materials, paper, wood,
plastics etc
B Class Fire ( Liquid-
Hydrocarbon ) - petrol, diesel,
kerosene etc.

C Class Fire (Gas ) – LPG,


Acetylene, methane, hydrogen
etc

D Class Fire (Metal) -


potassium, sodium, magnesium
etc.

E Class Fire-( Electrical


Hazards) - energized electrical
equipment. As long as it’s
“plugged in.”
FIRE
FIRE CLASS EXTINGUISHER
FIRE POINT at Site
WORKPLACE HAZARDS & SOLUTIONS

Know How to use Fire Extinguishers – PASS

Know Fire Emergency Response– RACE

998

R – “Rescue” any person/s in immediate danger (only if safe to do so)


A – “Alarm” Raise the alarm & follow emergency procedure
C – “Contain” Close doors / windows to contain the FIRE
E – “Extinguish” attempt to extinguish the fire
WORKPLACE HAZARDS & SOLUTIONS

FIRE – Emergency Evacuation


Need for a systematic Fire Evacuation Plan & Fire Drill?

Inadequate Fire Training


may leads to this
General Safety Requirements

FIRE – Emergency Evacuation


ON DISCOVERY OF FIRE FOLLOWING ACTION WILL BE TAKEN IMMEDIATELY
1. Stay calm, do not panic.

2. Shout FIRE, FIRE and raise alarm.

3. Inform others who may be in danger.

4. Shut down your equipment safely

5. With the minimum of personal risk, attack the


FIRE

6. In the event that the fire can not be extinguished,


evacuate the building using one of the
designated “Exit” routes and go to nearest
“ASSEMBLY POINT”

7. Inform Safety Dept / PM / CM

DO NOT USE LIFT/HOIST.


DO NOT RE-ENTER THE AREA UNLESS DECLARED SAFE.
Any Question???

You might also like