Professional Documents
Culture Documents
Analysis Bn61-18883a (Holder-Led PCB)
Analysis Bn61-18883a (Holder-Led PCB)
Quality control detects high injection point problem in part number: The height of the injection point is measured to determine if it is greater At the time of assembly with the PCB board, no
BN61-18883A, Problem is located in the assembly area of the PCB than the height of the Boss where the PCB board sits. The dimensional contact is generated between the injection point and
board. results show that the injection point has a maximum height of 2.18mm, the PCB. The injection point must not exceed
and the Boss 2.50mm, therefore which there is no possibility of it being 2.45mm.
related to any assembly problem.
OK NG
Condition Condition
Injection
Point
Assembly OK