This document provides a safe work procedure for MIG welding. It outlines three key hazards: falling or cutting obstacles in the work area, potential electrocution from water, and electrical shock or burns from exposed wires. The controls specified are to clean the work area, inspect cables and plugs, and always wear proper protective equipment like welding helmets and gloves. It also provides steps for turning on the welder and gas pressure safely.
This document provides a safe work procedure for MIG welding. It outlines three key hazards: falling or cutting obstacles in the work area, potential electrocution from water, and electrical shock or burns from exposed wires. The controls specified are to clean the work area, inspect cables and plugs, and always wear proper protective equipment like welding helmets and gloves. It also provides steps for turning on the welder and gas pressure safely.
This document provides a safe work procedure for MIG welding. It outlines three key hazards: falling or cutting obstacles in the work area, potential electrocution from water, and electrical shock or burns from exposed wires. The controls specified are to clean the work area, inspect cables and plugs, and always wear proper protective equipment like welding helmets and gloves. It also provides steps for turning on the welder and gas pressure safely.
Division: MAST Analysis By: Date: Apr/21/2008 Department: School division Supervisor: Frequency: Job Title: All Approved By: JSA Number: Job Title: 178 MIG Welder Job Performed By: R!"IR# $RS%&A' $R%T(TI) !"I$M&T* Weldin !as" #it$ appropriate lass% loves G&RA' &%TS* SA+ W%R, $R%(#"R* S-ep #escrip-ion .a/ard (on-rols & 'nspect #or" area (ould cut or fall because of obstacles or #ater could cause electrocution #$en #eldin (lean area and ensure t$ere is no #ater on t$e )oor before #eldin * 'nspect round cables and un cables for any #ires possibly e+posed ,lectrical s$oc" or possibly a burn 'nspect cables and plu ins #$ile #elder is s$ut o- . ,nsure you are #earin t$e correct PP, Welders )as$% #elders burn /ultraviolet0 and burns from t$e $eat of t$e #elder Al#ays #ear #elder1s $elmet% proper loves and ensure no s"in is e+posed 2 Turn on !'3 #elder ,lectrical s$oc" !a"e sure everyt$in is in proper order44Wor" in dry area44 5 Turn on as Pressure could cause t$e reulator to burst Stand to one side #$en openin cylinder valves 6 Perform tas"7Turn o- !'3 #elder ,lectrical s$oc" 8perate only after receivin trainin7 8perate only #it$ teac$er1s permision7 !a"e sure everyt$in is in proper order7 Wor" in dry area7 44 A"T.%RI0# M$'%1 I&+%RMATI%&* I# &"M2R* 'AST &AM* +IRST &AM* RMAR,S* 3%2 .IST%R1 I&+%RMATI%&* Pae & of * Print Date: Apr9*&9*::; #AT* RMAR,S* Approval Sinature: Date: Pae * of * Print Date: Apr9*&9*::;