Professional Documents
Culture Documents
CCNA Exploration2: Routing Protocols - Chapter 1 Exam: ROM Contains Diagnostics Executed On Hardware Modules
CCNA Exploration2: Routing Protocols - Chapter 1 Exam: ROM Contains Diagnostics Executed On Hardware Modules
Chapter 1 Exam
01. Which two statements correctly describe the components of a router? (Choose two.)
RAM permanently stores the configuration file used during the boot sequence.
ROM contains diagnostics executed on hardware modules.
NVRAM stores a backup copy of the IOS used during the boot sequence.
Flash memory does not lose its contents during a reboot.
ROM contains the most current and most complete version of the IOS.
Flash contains boot system commands to identify the location of the IOS.
02. Which
interfaces in the exhibit could be used for a leased line WAN connection? (Choose two.)
1
2
3
4
5
6
03. If a router cannot find a valid configuration file during the startup sequence, what will occur?
04. Which of the following is the correct flow of routines for a router startup?
05. What is the default sequence for loading the configuration file?
06. From what location can a router load the Cisco IOS during the boot process? (Choose two.)
RAM
TFTP server
NVRAM
setup routine
Flash memory
Terminal
packet switching
extension of network segments
segmentation of broadcast domains
selection of best path based on logical addressing
selection of best path based on physical addressing
08. What three processes does a router execute when it receives a packet from one network that is destined
for another network? (Choose three.)
decapsulates the Layer 3 packet by stripping off the Layer 2 frame header
uses the destination MAC Address in the IP Header to look up the next-hop address in the routing table
leaves the Layer 2 frame header intact when decapsulating the Layer 3 packet
uses the destination IP Address in the IP header to look up the next-hop address in the routing table
encapsulates the Layer 3 packet into the new Layer 2 frame and forwards it out the exit interface
encapsulates the Layer 3 packet into a special Layer 1 frame and forwards it to the exit interface
09. The network administrator needs to connect two routers directly via their FastEthernet ports. What
cable should the network administrator use?
straight-through
rollover
cross-over
serial
10. Refer to the exhibit. What can be concluded from the output of
the running-configuration of a router?
11. Which two statements describe characteristics of load balancing? (Choose two.)
Load balancing occurs when a router sends the same packet to different destination networks.
Load balancing occurs when the same number of packets are sent over static and dynamic routes.
Load balancing allows a router to forward packets over multiple paths to the same destination network.
Unequal cost load balancing is supported by EIGRP.
If multiple paths with different metrics to a destinations exist, the router cannot support load balancing.
VTY interface
console interface
Ethernet interface
secret EXEC mode
privileged EXEC mode
router configuration mode
DA!!sets the password to be used for connecting to this router via Telnet
If RouterC receives a packet that is destined for 10.5.1.1, it will be forwarded out interface Fa0/0.
DA!!If RouterA receives a packet that is destined for 192.168.3.146, it will be forwarded out interface
S0/0/1.
DA!!If RouterB receives a packet that is destined for 10.5.27.15, it will be forwarded out interface
S0/0/1.
If RouterB receives a packet that is destined for 172.20.255.1, it will be forwarded out interface S0/0/0.
If RouterC receives a packet that is destined for 192.16.5.101, it will be forwarded out interface S0/0/1.
19. What header address information does a router change in the information it receives from an attached
Ethernet interface before information is transmitted out another interface?