Professional Documents
Culture Documents
CM Next
No Document No. Document Title Rev
1. KTA.TB-PAC03-M59-012 Depressuring A 3 B
*Review Status:
1. Approved.2. Approved with comments.3. Rejected. 4. For Information.
PVGASD’s approval of any work/documentation shall in no way relieve AECC and/or VENDORS/SUPLLIERS of
any responsibility for performing the provisions of equipment/package in accordance with the project
requirements and relevant design documents.
*Notes:
1.Closed: Agreed, no further comments
2.Open: Still under discussion
3.For those comment sheet with code 2 from Company, if Contractor/Vendoragreed with all comments from
Company. Contractor/Vendor shall respond the comment sheet,revise and upgrade the document revision
to higher revision. The response sheet shall be attached to the document when submitting to Company.
4.For those comment sheet with code 2 from Company, if Contractor/Vendor disagreed with Company
comments. Contractor/Vendor shall have a discipline meeting with Company to finalize and sign off the
comment sheet, then revise and upgrade the document revision to higher revision. The response sheet shall
be attached to the document when submitting to Company.
REVIEW COMMENTS:
No. Company comments Contractor/Vendor Response Closed/
Open
Đề nghị đổi tên tài liệu thành “A
1 depressurization study for glycol AECC: Đã lưu ý
contactor C-101”
Yêu cầu trình bày tài liệu theo mẫu đã
quy định (header/footer, các đầu mục AECC: Đã lưu ý
2 ví dụ như Giới thiệu, mục tiêu, phương
pháp, kết quả, kết luận, etc.)
AECC: Diện tích lỗ Orifice
Trang 1 RO area: 129.6 mm2 = 12.8 Plate là 129.6 mm
2
Page 1 of 2
TIEN HAI – THAI BINH LOW PRESSURE GAS
DISTRIBUTION PIPELINE SYSTEM PROJECT
AECC cần thể hiện rõ shutdown valves AECC: Thể tích trong quá
5 nào là limits trong tính toán thể tích trình tính toán là khí thuộc
piping cho blow down phạm vi TEG Skid.
Với nhiệt độ thấp nhất -17.21 oC, đề AECC: A105N, A106 GrB có
nghị AECC bổ sung vào tài liệu kết luận MDMT = -29 0C phù hợp với
7 về sự phù hợp của vật liệu lựa chọn điều kiện cho Blowdown
cho blow down piping. piping.
Commented
by
Checked by
Phan Thị Hải Giang Lê Đức Thiện
Page 2 of 2