Professional Documents
Culture Documents
Same as rear
2 Front headers 25 mm 40 mm 35 mm headers and other
dents
Reduces repairs
25 mm single dent. 20 mm
Front & rear 20 mm without
4 If 2 dents or more, Any number of
corner posts Any number of dents. compromising
15 mm dent. dents.
structure
All side & front 35 mm dents (in or 35 mm internal cube 35 mm internal cube Ease of
5
panels out) intrusion intrusion measurement
Reasonable internal
35 mm dents (in or 50 mm internal cube 40 mm internal cube cube intrusion,
7 All roof panels
out) intrusion intrusion minimizes
commercial concern
Flooring height
8 5 mm 10mm 5 mm
difference
Entire container
10 As per below: As per below: As per below:
(ISO tolerance)
Equivalent to ISO +
20 mm measured in
30 mm measured in an outward direction
ISO + 10 mm 30 mm measured in
an outward from an outside
Side panels - (10mm beyond an outward direction
10. A direction from an recessed
outward corner fitting side from an outward
outward recessed corrugation. No
face) recessed corrugation
corrugation vessel stowage
operational issues at
ISO + 20 mm
40mm measured in
50 mm measured in
an upward direction
ISO + 4 mm an upward direction
from the upper
Roof panels - (4mm beyond corner from the upper faces Standardize roof
10. B faces of the top side
upward fitting top face) of the top side rails to dent in/out criteria
rails to an outward
an outward recessed
recessed
corrugation
corrugation
15 mm measured in
15 mm measured in
ISO + 5 mm an outward
Front panel – an outward direction
10. C (5mm beyond corner direction from an
outward from an outward
fitting end face) outward recessed
recessed corrugation
corrugation
NOTE: All other component criteria to remain unchanged from IICL 5 inspection tables.
IICL 6 Dry Van Inspection Table Revisions
Component Revisions
Component Reason/Comments
Table Reference
1 Flat bar top side rail 30 mm - Table 5.1 Same as IICL5 for tube top rail
2 Front headers 35 mm - Table 5.1 Same as rear headers and other dents