Professional Documents
Culture Documents
3. Question Regarding layout of general cabin equipment such as fire extinguishers, therapeutic oxygen, first aid kits etc.,
A.Only in overhead hat racks.
B. In overhead hat racks, in bulkhead cupboards and under crew seats.
C. In overhead hat racks and under passenger seats.
Correct answer B
4. Question Capacitors in a capacitive fuel contents indication system are wired in.33703
A.Parallel. 8
B. Cascade.
C. Series.
Correct answer A
8. Question Where on the surface of a typical aerofoil will flow separation normally start at high angles of attack?33044
A.Lower side leading edge.
B. Upper side leading edge.
C. Upper side trailing edge.
Correct answer C
9. Question Selection of the INS Mode Selector Unit (MSU) to ATT REF is made.34195
A.When navigation information is lost.
B. To feed information to the Captain and 1st Officers ADI displays.
C. When attitude information is lost.
10. Question When adjusting tyre pressures for the aircraft to fly to a warmer climate, the pressure should be.35292
A.Lower than normal.
B. Higher than normal.
C. Normal.
Correct answer C
11. Question In order for a captain to take control in a modern aircraft fitted with side-stick controls.34933
A.The captain would press the take-over button.
B. No action is required as the captain always has control.
C. The captain would move his/her control in the opposite direction.
Correct answer A
16. Question What is the maximum allowable concentration (by volume) of carbon dioxide in occupied aircraft compartm
A.0.5% (sea level equivalent).
B. 5% (sea level equivalent).
C. 0.005% (sea level equivalent).
Correct answer A
17. Question Wide body transport aircraft have cabin floor vents.33388
A.To equalise pressures above and below the floor after the loss of a cargo compartment door.
B. To ensure adequate ventilation of the underfloor areas.
C. To provide access to class A cargo compartments in the event of fire.
Correct answer A
18. Question After the compass has been corrected for Coefficient A, B and C. The remaining error is known as.33666
A.Apparent deviation.
B. Initial deviation.
C. Residual deviation.
Correct answer C
A.19. Question If the shuttle valve was stuck in the normal position.35226
B. Normal braking will not be available.
C. Neither system will be available.
80_35226 Emergency braking will not be available.
Correct answer C
22. Question Where the aircraft passenger seating capacity exceeds 149 but less than 200 then.34680
A.2 megaphones are required.
B. 3 megaphones are required.
C. 1 megaphone is required.
Correct answer A
27. Question In the event of multiple AFDX switch losses on both of the ADCN networks.35559
A.There is no functional effect on the aircraft systems, but this is a no-go failure.
B. There will be no aircraft systems effect due to the redundant duplication of networks is the ADCN, and the aircraft can
C. There is a functional effect on the aircraft systems, and this will trigger the Master Caution, and is a no-go failure.
Correct answer C
30. Question Before the aeroplane is moved from the loading pier, the pilot must.34073
A.Set the altitude to be fed into the INS.
B. Insert the latitude and longitude of the pier into the INS.
C. Insert the latitude and longitude of the first waypoint into the INS.
Correct answer B
31. Question Under static load the pressures in the oil and gas of a gas/oil shock absorber with separator are.35282
A.Both pressures are the same.
B. The oil pressure is higher than the gas pressure .
C. The gas pressure is higher than the oil pressure.
Correct answer A
35. Question Aircraft emergency escape slides are usually pressurised with.34658
A.CO2.
B. Helium.
C. Oxygen.
Correct answer A
38. Question An aeroplane performs a straight and level horizontal flight at the same angle of attack at two
different altitudes: (all other factors of importance being constant, assume ISA conditions and no
A.The TAS at both altitudes is the same.
B. The TAS at the higher altitude is lower.
C. The TAS at the higher altitude is higher.
Correct answer C
40. Question An increase of both the volume of oil, and of oil temperature, could be caused by.34403
A.The oil cooling not being sufficient.
B. More heat being generated inside the CSD.
C. The CSD having too high input speed.
Correct answer A
41. Question The stall speed in a 60 degress banked turn increases by the following factor.32986
A.1.41
B. 2.00
C. 1
Correct answer A
43. Question GPWS INOP light comes on. Engineer would initially.33725
A.Change the GPWC for a serviceable one.
B. Do a level 3 self test to check that the database is up-to-date.
C. Do a Level 2 self test to determine the source of the fault.
Correct answer C
44. Question A NRV (None Return Valve or Check Valve) is usually fitted before each circuit in the supply line
to prevent fluid return. Fluid return might be caused by.35096
A.ACOV operation.
B. Surge return pressures.
C. Another circuit in the system demanding the fluid.
Correct answer C
51. Question What should you be cautious about when touching pitot probes?33954
A.They can be extremely hot after flight.
B. They can build up a very high static charge during flight which takes some time to dissipate.
C. They can be extremely cold after flight.
Correct answer A
53. Question The rate of turn information from a turn coordinator (compared to a Turn and Slip) is.33864
A.More instantaneous.
B. More accurate.
C. Less accurate.
Correct answer B
54. Question When refuelling.34841
A.It is important to fill the expansion space in the tank.
B. The fuel nozzle will automatically cut off the supply when the tank is full.
C. It is important not to fill the expansion space in the tank.
Correct answer C
58. Question After take-off the slats (when installed) are always retracted later than the flaps. Why?32838
A.Because SLATS EXTENDED gives a large decrease in stall speed with relatively less drag.
B. Because SLATS EXTENDED provides a better view from the cockpit than FLAPS EXTENDED.
C. Because FLAPS EXTENDED gives a large decrease in stall speed with relatively less drag.
Correct answer A
61. Question Which vapour cycle system component is required to be most strongly constructed.33532
A.Evaporator and condenser are identical in construction.
B. Evaporator.
C. Condensor.
Correct answer C
62. Question If the leading edge of a variable incidence stabilizer is moved downwards, there will be a.32912
A.Nose down moment on the aeroplane.
B. Nose up moment on the aeroplane.
C. Stabilizing effect on the aeroplane.
Correct answer B
63. Question On a C.S. driven generator, operation of the Disconnect Solenoid will disconnect the generator drive and.344
A.It will automatically reset itself when the fault is rectified.
B. It can only be reset when all loads are switched off.
C. Resetting can only be carried out on the ground.
Correct answer C
75. Question One disadvantage of the swept back wing is its stalling characteristics. At the stall.32942
A.Tip stall will occur first, which produces a nose-down moment.
B. Wing root stall will occur first, which produces a rolling moment.
C. Tip stall will occur first, which produces a pitch-up moment.
Correct answer C
82. Question Why is an aerial tuning unit used in a high frequency (HF) communication system?34339
A.To select the transmission/reception frequency in the HF band.
B. To electrically lengthen or shorten the aerial for optimum matching of impedance.
C. To extend or retract the aerial and so vary its physical length.
Correct answer B
83. Question An indicator pin is protruding from a portable fire extinguisher. What does it indicate?34769
A.Bottle is empty.
B. Bottle is full.
C. The bottle is still pressurized.
Correct answer A
88. Question Whilst operating paralleled AC constant frequency generators, it is important to maintain generator outputs
A.To prevent a circulating current of considerable magnitude developing between two or more generators.
B. To prevent a circulating current developing between two or more TRUs.
C. To prevent CSD shock loading.
Correct answer A
89. Question ADF works by using.34042
A.Sense aerial.
B. Both loop and sense aerial.
C. Loop aerial.
Correct answer B
91. Question A piece of structure which must be replaced at a specified number of cycles, flying hours or
years, regardless of its physical condition is what type of item?33159
A.Safe-life.
B. Condition monitored.
C. Fail-safe.
Correct answer A
92. Question What is a characteristic of a direct reading compass instrument light wiring?33920
A.It must be sheilded or twisted wire pair.
B. It must be 16AWG.
C. It must be aluminium.
Correct answer A
98. Question If the Emergency Evacuation Command button is operated in the cockpit, it can be cancelled (reset).35589
A.Either by the cabin crew at the cabin crew stations or the flight crew in the cockpit.
B. Only by the cabin crew at the cabin crew stations.
C. Only by the flight crew in the cockpit.
Correct answer A
99. Question What is the difference between Alert Height and Decision Height?34295
A.They are the same.
B. Alert Height is based upon the visual reference of the runway, and Decision Height is based upon the mechanical integr
C. Decision Height is based upon the visual reference of the runway, and Alert Height is basedupon the mechanical integr
Correct answer C
101. Question A battery for use on aircraft must have a capacity of.34349
A.50%
B. 80%
C. 90%
Correct answer B
102. Question When a vibrating rod ice detector has de-iced, the warning lamp on the flight deck.35068
A.Goes out immediately.
B. Goes out after one more cycle.
C. Goes out after a set period of time.
Correct answer C
106. Question The extension to the rudder (shaded portion shown on the diagram), is provided to. 33428
A.Provide aerodynamic assistance for the pilot when moving the rudder.
B. Prevent control surface flutter.
C. Make the pilot aware of the aerodynamic forces encountered when moving the control.
Correct answer A
108. Question Which is the greatest stress imposed on a pressurised fuselage due to the cabin pressure?33584
A.Hoop stress.
B. Axial stress.
C. Shear stress.
Correct answer A
110. Question During flap deployment, the nose down tendency is opposed by the.34895
A.Increased angle of attack.
B. Increased tailplane downwash.
C. Decreased angle of attack.
Correct answer B
111. Question In a Central Air Data Computer (CADC) system, Mach information is derived from.33753
A.Indicated airspeed and altitude.
B. Indicated air speed and total air temperature.
C. Pitot and static pressures.
Correct answer A
112. Question The ordinary incandescent lamp uses a.35349
A.Tungsten filament within a iodine filled envelope.
B. Tungsten filament within a gas filled envelope.
C. Steel wire filament within a vacuum envelope.
Correct answer B
113. Question A wing with a very high aspect ratio (in comparison with a low aspect wing) will have.32835
A.Poor control qualities at low air speeds.
B. Higher stall speed.
C. Increased drag at high angles of attack.
Correct answer B
114. Question An electroinc flight bag which is portable and doesnt have any electrical connection to the aircraft whatsoe
A.Class 1.
B. Class 2.
C. Class 3.
Correct answer A
115. Question To shut-off the LP fuel supply to the engine for the purpose of engine removal you would.34831
A.Close the HP fuel lock.
B. Pull the fire handle.
C. Close the cross bleed valve.
Correct answer B
116. Question If the disconnect solenoid of a CSD is energized when the engine is stopped.34460
A.The clutch will open immediately in the normal way.
B. Nothing will happen.
C. The disconnect device is triggered and the clutch will be damaged when the engine is started.
Correct answer B
121. Question On Large transport aircraft fuel is delivered to each engine using.34816
A.A separate system for each engine.
B. A parallel system.
C. The same system for each engine.
Correct answer A
124. Question The cross sectional area of a secondary conductor must be not less than.33213
A.22 SWG x 0.25
B. 18 SWG for a single wire.
C. 22 SWG x 0.5
Correct answer B
131. Question An aeroplane flying above the Critical Mach No. will usually experience.33090
A.A nose up pitch.
B. A nose down pitch.
C. An oscillation in pitch.
Correct answer B
132. Question Differences between Core Processing Input/Output Modules (CPIOMs) are determined by.35554
A.The type of system the computer interfaces with.
B. The memory and CPU requirements.
C. The types of applications loaded onto them.
Correct answer A
133. Question An aircraft has a maximum differential pressure of 8.5 PSI at cruising altitude. If the ambient
pressure is 2.9 PSI, the pressure inside the cabin at cruising altitude would be.33542
A.8.5 PSI
B. 11.4 PSI
C. 5.6 PSI
Correct answer B
135. Question Wing spoilers, when used asymmetrically, are associated with.33068
A.Rudder.
B. Elevators.
C. Ailerons.
Correct answer C
136. Question The fire detection system of an aircraft must contain.34749
A.An amber flashing light on the centre console and a warning siren.
B. Approved, quick acting fire or overheat detectors in each designated fire zone.
C. A red master caution light and an audible fire warning bell.
Correct answer B
140. Question Wing bending and shear loads are taken by.33413
A.Spar cap.
B. Skin.
C. Main spar.
Correct answer C