Professional Documents
Culture Documents
Week 1 Assignment 1 PDF
Week 1 Assignment 1 PDF
reviewer1@nptel.iitm.ac.in ▼
Unit 2 - Week 1
Course
outline Week1 Assignment
The due date for submitting this assignment has passed. Due on 2017-08-07, 23:59 IST.
How to access
the portal Submitted assignment
Lecture 1: N/m3
Introduction N/m2
Lecture 2: N/m
Analysis of N.m
Stress- I
No, the answer is incorrect.
Lecture 3:
Score: 0
Analysis of
Stress- II Accepted Answers:
N/m2
Quiz : Week1
Assignment
2) What is the unit of shear strain? 1 point
Week 1:
Assignment No unit
Solution m
Feedback for m-1
week 1 m2
Week 2 No, the answer is incorrect.
Score: 0
Week 3
Accepted Answers:
No unit
Week 4
3) What is the unit of Young’s Modulus? 1 point
Week 5
N/mm2
Week 6 N/m2
Pa
Week 7
All of the above
Week 8 No, the answer is incorrect.
Score: 0
Week 9
Accepted Answers:
All of the above
Week 10
4) A uniform steel rod, 6mm in diameter and 0.5m long is subjected to a tensile force of 3kN. 1 point
Week 11 Find the stress in the bar and its elongation. (E=200 GPa)
6) Determine the maximum shear stress in rivets for the figure shown. P= 25 kN, diameter of 1 point
the rivet= 20 mm.
79.57 MPa
39.7 Pa
79.57 Pa
39.8 MPa
7) Find the bearing stress between the bolts and the plates. The thickness of each plate is 10 1 point
62.5 MPa
125 MPa
62500 Pa
125000 Pa
No, the answer is incorrect.
Score: 0
Accepted Answers:
62.5 MPa
8) Determine the resisting shear stress in the rivets. P= 30 kN, diameter of rivets = 1 point
20 mm.
https://onlinecourses.nptel.ac.in/noc17_ce22/unit?unit=5&assessment=14 2/4
07/12/2017 Strength of Materials - - Unit 2 - Week 1
190.9 MPa
47.7 MPa
95.5 MPa
23.8 MPa
9) The state of stress at a given point is given as following. Calculate the principal stresses. 1 point
Zero
Maximum
Minimum
Either maximum or minimum
https://onlinecourses.nptel.ac.in/noc17_ce22/unit?unit=5&assessment=14 3/4
07/12/2017 Strength of Materials - - Unit 2 - Week 1
Funded by
Powered by
https://onlinecourses.nptel.ac.in/noc17_ce22/unit?unit=5&assessment=14 4/4