Professional Documents
Culture Documents
in
Announcements About the Course Q&A Progress Mentor Review Assignment Course Recommendations
Binary Signaling
How does an NPTEL
online course work? M-array Signaling
Quadrature Amplitude modulation
MATLAB All of the above
Week 1 2) The change in amplitude of carrier in accordance to the digital message signal then it is called as 1 point
3) Which one is the non-coherent mode of binary phase shift keying? 1 point
Week 7
Quadrature Phase Shift Keying
Week 8
Differential Phase Shift Keying
Amplitude Shift Keying
Week 9
Binary Phase Shift Keying
Week 10 Yes, the answer is correct.
Score: 1
Week 11 Accepted Answers:
Differential Phase Shift Keying
Week 12
4) The modulation techniques used to convert analog signal into digital signal are 1 point
Download videos
Pulse code modulation
5) If bandwidth is of primary concern then which one of the following schemes is generally not considered? 1 point
ASK
PSK
FSK
DPSK
7) In which one of the following modulation techniques RF binary signals are transmitted as given? 1 point
0 : √(2)p(t)cos[wc + Δw/2]t
1 : √(2)p(t)cos[wc − Δw/2]t
ASK
PSK
FSK
MPSK
Thrice
Twice
Same
Four times
Entropy
Efficiency
Coded signal
None of the above
10) The frequency of carrier signal is modified in accordance to the message signal then it is called as _________ 1 point
11) Which of these values of μ would correspond to the linear amplification? 1 point
=0
=1
>0
<0
12) ____________ is defined as the ratio of the input signal-to-noise ratio to the output signal-to-noise ratio 1 point
Signal-to-noise ratio
Noise figure
Noise Temperature
None
13) Which one of the following noises arises in electronic devices, such as in diodes and transistors, due to the discrete nature of current flow? 1 point
Shot noise
Thermal noise
Gaussian noise
Random noise
Switching transients
Lightening strikes
Power line load switching
All of the above
16) ____________fading occurs if the coherence bandwidth happens to be smaller than that of the bandwidth of the given signal. 1 point
Time selective
Fast fading
Frequency selective
Flat
Error correction
Error detection
Error correction and detection
None of the above
Π/2
Π/4
2Π
20) Code rate r, k information bits and n as total bits, is defined as 1 point
r = k/n
k = n/r
r=k*n
n=r*k