You are on page 1of 3

A steel beam is made up of a wide flange section whose total depth is 0.

45 m, width of the flange is


150 mm and has a flange thickness of 15 mm. Its web thickness is 10 mm and has a simple span 10000
mm. It supports a superimposed uniformly distributed load of 20kN/m and a 7000 N concentrated load
at midspan. Ix = 274.7x106 mm4 and Iy = 3.28x106 mm4. Weight of the beam is 50 kg/m. Determine the
following:

1.) Average shearing stress in the beam


a. 23.45 MPa
b. 23.54 MPa
c. 24.53 MPa
d. 24.35 MPa

2.) Maximum shearing stress in the beam


a. 27.38 MPa
b. 28.73 MPa
c. 27.83 MPa
d. 28.37 MPa

3.) Maximum bending stress in the beam


a. 435.04 MPa
b. 435.03 MPa
c. 435.02 MPa
d. 435.01 MPa

4.) How many radians is equivalent to 320 grads?


a. 4.03 radians
b. 5.03 radians
c. 6.03 radians
d. 7.03 radians

5.) For the manometer setup shown, determine the difference in pressure between A and B.
a. 15.86 kPa
b. 16.58 kPa
c. 15.68 kPa
d. 18.56 kPa

6.) Ed weighs about 804.42 N. What is his mass in kilograms?


a. 72 kg.
b. 82 kg.
c. 92 kg.
d. 102 kg.
7.) What is the weight of a 45-kg boulder if it is brought to a place where the acceleration due to
gravity is 395 m/s per minute?
a. 1738.37 N
b. 832.92 N
c. 468.20 N
d. 296.25 N

A rectangular reinforced concrete beam has a length of 3 m width of 300 mm and effective depth of
500 mm. The beam is reinforced with 3-25 mm diameter main bars. f’c = 35 MPa fy = 415 MPa. Total
depth of the beam is 0.6m. In addition to live load and its own weight the beam carries 150 mm thick
concrete slab that is 4m wide. Concrete weight is 24 kN/m. At ultimate condition U = 1.2 DL + 1.6 LL.

8.) Calculate the depth of the stress block


a. 68.49 mm
b. 68.94 mm
c. 69.48 mm
d. 69.84 mm

9.) Calculate the distance from the extreme compression fiber to neutral axis.
a. 86.51 mm
b. 86.15 mm
c. 85.61 mm
d. 85.16 mm

10.) Find the maximum uniform service (unfactored) live load acting over the entire span that can be
supported by the beam in kN/m.
a. 126.3 kN/m
b. 127.3 kN/m
c. 128.3 kN/m
d. 129.3 kN/m

11.) Given a triangle ABC such that A = 40°, a = 10m, and b = 15m. How many possible triangles can be
formed?
a. 0
b. 1
c. 2
d. 3

12.) What is the 15th term of the progression 12, 18.5, 25, …?
a. 101
b. 102
c. 103
d. 104

13.) Renz set out from a certain point and travelled at the rate of 6 kPh. After Renz had gone two
hours, Suzette set out to overtake Renz and went 4 km the first hour, 5 km the second hour, 6 km the
third hour and so on gaining 1 km every hour. How many hours after Suzette left will they be
together?
a. 6
b. 7
c. 8
d. 9

14.) A trainee in a computer company takes 0.8 times as long to assemble each computer as he took
to assemble the preceeding computer.If it took him 30 minutes to assemble the first computer, find
how long it takes him to assemble the five computer units.
a. 102
b. 202
c. 302
d. 402

15.) Solve for the value of the equation if -3 is a solution of 6x+14 = -7-x.
a. -4
b. 0
c. -2
d. -9

16.) What is the value of x if 1, ¼, 1/x, 1/10, …form a harmonic progression?


a. 5
b. 6
c. 7
d. 8

17.) If Ana was four times as old as Billy eight years ago, and if Anna will be twice as old as Billy eight
years hence, how old is Billy now?
a. 8
b. 16
c. 24
d. 32

18.) The angle of elevation of a pole 10 m horizontally from it is three times the angle of elevation at a
point 50 m from it. Find the angle of elevation 10 m from the pole.
a. 62.12°
b. 41.14°
c. 58.24°
d. 20.71°

You might also like