Professional Documents
Culture Documents
Place: NANDED
Date:
1
Government Polytechnic, Nanded
Mechanical Engineering Department
Academic Year (2019-20)
Micro project
Subject: AMP
Branch: ME 5I (RR).
2
GOVERNMENT POLYTECHNIC, NANDED
MICRO PROJECT
Academic year: 2019-20
PROGRAM: ME.
PROGRAM CODE: ME 5I (RR)
COURSE:
COURSE CODE:
NAME OF GUIDE: -
3
Government Polytechnic, Nanded
Mechanical Engineering Department
Academic Year (2019-2o)
PART A - PLAN
Micro Project Proposal
(For 5th Semester)
1. Brief Introduction:
Hand saw
A saw is a hand tool with a toothed blade used to cut hard materials such as wood or
bone. They are among the oldest known tools. Innovations made over thousands of years
are still present in modern, mass-produced examples.
The first flint saws appeared during the early Paleolithic Era, between 60,000 and
10,000 B.C. Stone saws and composite saws made of stone blade lets or "microliths" set
into a bone handle also were made during this time. The first metal blades were made
possible by the discovery of copper about 4,000 years ago.
Spring
There are several types of springs. One of the most common consists of wire wound into
a cylindrical or conical shape. An extension spring is a coiled spring whose coils
normally touch each other; as a force is applied to stretch the spring, the coils separate. In
contrast, a compression spring is a coiled spring with space between successive coils;
when a force is applied to shorten the spring, the coils are pushed closer together. A third
type of coiled spring, called a torsion spring, is designed so the applied force twists the
coil into a tighter spiral. Common examples of torsion springs are found in clipboards
and butterfly hair clips.
Still another variation of coiled springs is the watch spring, which is coiled into a flat
spiral rather than a cylinder or cone. One end of the spring is at the center of the spiral,
and the other is at its outer edge.
4
For example, if increased strengths are required, it is absolutely essential to subject the
parts after pressing to a heat treatment process in order to be able to influence the
mechanical properties specifically.
3. Action plan:
S. Details of activity Planned Planned Name of responsible
No start finish team members
. date Date
1. Selection of group member. Mr
4. Resources Required:
S. Name of Resource / material Specification Qty Remarks
no.
1. Flex For making chart 1
2. pipes To support chart 1
3. Gum To stick the flex 1
4. Internet To Get the information -
5. Hooks To hang with nills