Professional Documents
Culture Documents
Basic Electronic Project Report Variable DC Power Supply: Hitec University Taxila Cantt
Basic Electronic Project Report Variable DC Power Supply: Hitec University Taxila Cantt
Electrical department
SUBMITTED TO:
LECTURER:. Sir .OBAID SABIR
LAB ENGINEER: SIR.
Group members.
Introduction.
Background.
Abstract
Method of procedure.
1. Circuit diagram.
2. List of components.
3. Pre-assembling on breadboard.
4. PCB making and soldering components.
5. Working.
6. Output voltage formula
7. Results.
Conclusion.
Refrencess
GROUP MEMBERS:
ZEESHAN KHAN (EE-151).(team leader)
ZEESHAN MOHSIN (EE-150).
BACKGROUND:
Our respectable teacher Eng obaid sabir give us a project to make a variable dc power supply We
got the idea of this project while reading the full wave rectifier and almost every group use the full
wave rectifier with little bit changing in their circuit.
CIRCUIT DIAGRAM:
The circuit we use for this project is given below.
WORKING :
The main working principle of this project is full wave rectification which is
done by bridge configuration in which we are using 4 diodes which rectifies
the output of the step-down transformer which step- down the 220 AC v to 9
AC volts .here we are using a voltage regulator which give constant
voltage ,here we are using 7805 which give 5 volts .these regulators are
available in various outputs like 6v,9v,12v and 15 v.
Now the main task is to get variable output for this we use the pair of voltage divider resistors to
increase the output of the regulator and in which of resistance is variable so when we increase or
decrease the value of that resistor the output voltage of the regulator will also change and we get
In this circuit we use three capacitor , c1 and c2 are use to get constant input to the regulator
moreover it also help to reduce the sharp peaks in the output . connect the 0.27 uF capictor to
close to the input of the regulator and the 10 uf capacitor to the output because these capacitor
reduse the noise and also help to reduse the ripples produce by the regulator so that regulated
output has less ripples.
REFRENCESS :
I collected the data from the mention below sites our teachers and our text book also helps a lot.
www.youtube.com
www.pcbheaven.com
www.circuittoday.com
www.Wikipedia.com