Professional Documents
Culture Documents
Series A To E (Part 6) .Docx July 2019-1 PDF
Series A To E (Part 6) .Docx July 2019-1 PDF
a. First page only b. concerned page only c. both a & b are correct d.
all the pages
3. MEL is applicable to D B I
a. cannot form part of the MEL c. can form part of the MEL without
any conditions.
b. AME shall inform to RAO d. AME need not to inform any one.
a. which will increases the maintenance action c. which will increase crew
load
b. those items which are not repairable d. those items which are inoperative
most of the time
10. Aircraft landing lights (Cat ‘A’) has been placed under MEL It should be D B I
repaired within
11. For the purpose of categorization of MEL items, the ‘flight day’ used in the C B I
MEL shall mean a 24 hour period. This shall be from
b. To provide continued operation of the aircraft for extended periods with MEL
items unserviceable
c. Not to permits reduced safety in order to fly to a base where repairs can be
made, but a philosophy of permitting safe operations for takeoff from a
maintenance base or en-route stop.
15. The MEL/CDL shall be prepared on the basis of ________and got approved A B I
from ____
b. MEL must be less restrictive than MMEL d. MEL should not be less
restrictive than MMEL
17. The following rules states that no aircraft shall be released to flight with defects A B I
/ damage unless these are covered in the approved deficiency list
19. Items placed in cat ‘C’ of the MEL, shall be required to be repaired within D B I
20. Aircraft rules 7B specifies that all Indian registered aircraft shall carry on board B B II
21. A check list that is displayed to the flight crew by means of some electronic D B II
device is
22. A list containing items of inspection to be performed by the flight crew in the A B II
order listed and in the circumstances as indicated for ensuring safe operation of
an aircraft is called
a. Containing action to be performed by flight crew in the order listed and in the
circumstances as indicated for ensuring safe operation of aircraft
d. check list to the followed whenever the aircraft wants to take off in
emergency
a. alterations to check list can be carried out by the operator on his own,
depending on his experience
b. operator can prepare the Cockpit Check List & Emergency Check List based
on their experience
c. the check list will list the function of each flight crew member against each
item of the list d. none of the above
25. Cockpit Check List and Emergency Check List for each type of aircraft is B B II
provided by
26. Cockpit Check List and Emergency Check List are generally provided by D B II
28. Operator who do not receive check list along with the aircraft shall have to C B II
contact
a. DGCA c. manufacturers
29. Cockpit check list in paper form shall be carried on board by each aircraft D B II
30. While using the cockpit check list, the procedure of challenge and response is C B II
applicable to
31. Any part of an aircraft, soundness and correct functioning of which, when fitted B C I
on an aircraft, is essential for the continued air worthiness or safety of aircraft,
or occupant is called
a. item of equipment c. bonded store
32. A defect in an aircraft which recurs in spite of rectification attempt, on the same C C I
aircraft
39. When the maintenance of an a/c is contracted to an AMO by the operator, the B C I
responsibility of reporting defects observed during the maintenance on such a/c
is that of
40. Detailed information regarding major defects or which are serious in nature and D C I
attracting public attention shall be submitted by scheduled operators.
43. Which of the following fleet performance data is given by scheduled operators D C I
in their monthly report to RAWO
44. Fleet performance and engineering statistics report will be forwarded to RAWO C C I
by non-scheduled operators
45. Records associated with the defects and their rectification action shall be B C I
preserved for
c. in flight sectors of short duration, even when stabilized conditions are not
obtained.
d. AOTA
48. When the crew have failed to make an entry in the PDR after a flight, then C C II
b. AME will certify the aircraft for the next flight, by conforming from the pilot
by telephone that there is no defect during the previous flight.
c. AME shall not certify the aircraft till, the defect register for the previous
flight is filled and signed by crew d. AME will certify the aircraft, with
concurrence from QCM
49. Maintenance of fuel and oil uplift and consumption records is applicable to C D V
50. The average fuel and oil consumption of engines will be recorded in D D V
51. The average fuel and oil consumption of engines, the concern entry will be B D V
made by
55. Organization located within India will apply for initial issue of approval in D E I
57. Who will ensure that the work done at sub contractors’ facility meets the B E I
manufacturers / DGCA requirements
58. Manager who has authority for ensuring that all the tasks of the approved C E I
organization can be financed and carried out to standard required by DGCA
59. How many copies of manuals are required to be submitted for approval of a B E I
firm?
60. A document dispatched along with aircraft components certifying that the B E I
component has been obtained from an approved source after over haul /repair
/manufacture is known as
61. Foreign organizations will submit the application for initial approval to A E I
62. Who will ensure that all personnel in an organization are appropriately trained B E I
and qualified to accomplish the work.
a. QC manager b. accountable manager c. Nodal officer d. Chief
Instructor
63. A management system for programming and coordinating the ongoing quality C E I
and improvement efforts of the various groups in an organization in accordance
with the requirements of DGCA and any specific requirement of the
organization or customer is called as
64. If accepted quality manager ceases to hold the position, the appointment of his C E I
successor must be
d. AOTA
68. Internal audit report copy of not older than ___________ shall be enclosed with C E I
the organization renewal application.
69. Approved Organizations must retain a copy of all inspection records and any A E I
associated data for _______ to which the work relates was released.
73. Category ‘E’ organization will have to get their bulk/packed facilities and tanks D E VI
or bulk mobile equipment approved by
74. For how long the records of Cat ’E’ organization is maintained C E VI
78. Essential records of cat ‘E’ organization are retained for a period of D E VI