Professional Documents
Culture Documents
Ordering Information
IN_x Inputs
H-bridge FETs
IO = 1A
On-resistance Rds(on) 95 mΩ
Upper and Lower total
IO = 3A
On-resistance Rds(on) 105 mΩ
Upper and Lower total
TSD Protections
Block Diagram
OCP
Level MG1
IN_A 1 Shifter
MG1 MG3
MG2
High-side /
Low-side
MG3
Driver
Level MG4
IN_B 2 Shifter
MG2 MG4
TSD
3
GND
Top View
IN_A OUT_A
IN_B OUT_A
GND OUT_B
VCC OUT_B
Pin Descriptions
Application
IN_A 1 8
IN_A OUT_A
R1
IN_B 2 7
IN_B OUT_A 5 ohm
M
C4
C3
3 6
0.1μF
GND OUT_B 0.1μF
4 5
VCC OUT_B
C1
C2
0.1uF
220μF
Circuit Descriptions
The function descriptions of capacitors on the application circuit:
1. C1、C2: Power supply VCC pin capacitor:
1) The capacitor can reduce the power spike when the motor is in motion. To avoid the IC directly damaged
by the VCC peak voltage. It also can stabilize the power supply voltage and reduce its ripples.
2) The C1 capacitor can compensate power when motor starts running.
3) The capacitor value (μF) determines the stability of the VCC during motor in motion. If the large voltage
power or a heavy loading motor is used, then a larger capacitor would be needed.
4) On the PCB configuration, the C1、C2 must be mounted as close as possible to VCC pin .
2. C3, R1: The across-output capacitor and resistor
1) The capacitors can reduce the power spike of motor when operating. Therefore, a 0.1μF capacitor is
recommended. The resistor can reduce output voltage switching noise when OCP operating.
Therefore, a 5ohm resistor is recommended
2) On the PCB configuration, the C3 and R1 must be mounted as close as possible to OUT_A&B.
3) The C3 and R1 must be added to the general application.
3. C4 : The across-motor capacitor
1) The C4 capacitors can reduce the power spike of motor in start running. A 0.1μF capacitor is
recommended.
2) The C4 capacitor must be added to the general application.
M M M M
Q2 Q4 Q2 Q4 Q2 Q4 Q2 Q4
2) Over-temperature protection
If the IC junction temperature exceeds 150 ゚ C (Typ.), the internal over-temperature protection function will be
triggered, partial FETs in the H-bridge are disabled, that will ensure the safety of customers' products. If the
IC junction temperature falls to 110 ゚ C(Typ.), the IC resumes automatically.
Marking Identification
NOTE:
Row1 : Logo
Row2 : Device Name
Row3 : Wafer Lot No use five codes + Assembly Year use one code + Assembly Week use
two codes