Professional Documents
Culture Documents
The tolerance on the length of steel plate and sheet shall be as given in table 1.
+ 25 +5
Under 6.00
0 0
Under 6300
+ 25 + 10
6.00 and over
0 0
+ 0.5 % + 10
Under 6.00
0 0
6300 and over
+ 0.5 % + 15
6.00 and over
0 0
The maximum value of lateral warpage of steel plate, sheet and strip shall be as given in Tables 2.
Remarks : 1. To the lateral warpage of steel plates and sheets under 250 mm in width.
2. This table not apply to the steel plate and sheet as rolled with edge.
3. The application of the lateral warpage of steel plate and sheet shall be in accordance with Fig. 1.
6.00 to 10.00 excl. ± 0.60 ± 0.60 ± 0.65 ± 0.75 ± 0.85 ± 0.95 ± 1.05
10.0 to 16.0 excl. ± 0.60 ± 0.60 ± 0.70 ± 0.80 ± 0.90 ± 1.00 ± 1.1
16.0 to 25.0 excl. ± 0.70 ± 0.70 ± 0.80 ± 0.90 ± 1.00 ± 1.2 ± 1.3
25.0 to 40.0 excl. ± 0.80 ± 0.80 ± 0.90 ± 1.0 ± 1.1 ± 1.3 ± 1.4
40.0 to 63.0 excl. ± 0.90 ± 0.90 ± 1.0 ± 1.2 ± 1.3 ± 1.4 ± 1.5
63.0 to 100.0 excl. ± 1.1 ± 1.1 ± 1.2 ± 1.4 ± 1.5 ± 1.6 ± 1.7
100.0 to 160.0 excl. ± 1.3 ± 1.3 ± 1.4 ± 1.6 ± 1.7 ± 1.8 ± 1.9
160.0 and over ± 1.6 ± 1.6 ± 1.7 ± 1.9 ± 2.0 ± 2.1 ± 2.2
Remarks : When required, the tolerance in the above table may be one - sided either minus or plus side, provided
that the total range of the tolerance in this case shall be equal to the total range of the tolerance given in the above
table.