Position(s) of Groove All Temperature Range None Welding Progression: Up Yes Down No Time Range N.A Positions(s) of Fillet All GAS (QW-408) PREHEAT (QW-406) Percent Composition Preheat Temp. Min 50ºF(10ºC) UP TO 3/4", 200ºF OVER 3/4" Gas(es) (Mixture) Flow Rate
Preheat Maintenance During welding operation Trailing None ------- ------ (Continuos or especial heating, where applicable, should be recorded) Backing None ------- ------
ELECTRICAL CHARACTERISTICS (QW-409)
Current AC or DC DC Polarity GTAW: S.P,SMAW: R.P Amps (Range) See Table Volts (Range) See Table (Amps and volts range should be recorded for each electrode size, position, and thickness, etc. This information may be listed in a tabular form similar to that shown below.)
Tungsten Electrode Size and Type 3/32", EWTH-1 o EWTH-2
(Pure Tungsten, 2% Thoriated, etc.) Mode of Metal Transfer for GMAW N.A (Pure Tungsten, 2% Thoriated, etc.) Electrode Wire feed speed range N.A
TECHNIQUE (QW-410) GTAW SMAW
String or Weave Bead String /Slight weave String /Slight Weave Orifice or Gas Cup Size 1/4"to 3/8" N.A Initial and Interpass Cleaning ( Brushing, Grinding, etc) Grinding & brushing Grinding & brushing
Method of Back Gouging None None
Oscilation 2-1/2 times rod diameter 2-1/2 times rod diameter max. Contact Tube to Work Distance N.A N.A Multiple or Single Pass (per side) Single or Multiple Single or Multiple Multiple or single Electrodes Single Single Travel Speed (Range) N.A N.A Peening Not Allowed Not Allowed Other None None
Filler Metal Current Travel Other (e.g., Remarks, Coments Hot
Weld Layer Process Volt Range Speed Wire Addition, Techinique, Torch (s) Class Dia Type Polar. Amp Range Range Angle, etc)