Professional Documents
Culture Documents
Structural
Simulation of a steel structure being lifted
Analysis COL-JD-01-A
ㅡ
Objectives The structure of this project belongs to a container that will hold a
mechanical equipment, which has a load of 600kg, distributed in 1.30 m².
The first part of the analysis must answer the question whether the
structure modelled in Revit is able or not to support the load (as well as
the own weight of the rest of the container) in a static situation,
supported directly on the groud. If the container is not able to support
the load, what actions are necessary to enhance the structure capacity?
The second part of the analysis must check if the container is able to be
lifted in two different ways. These liftings must be analysed separatedly,
and they BOTH must be done. The first way is lifting by steel cables,
attached to the top of the container, on the top for corners of the
structure, as image below:
The second mean of lifting is using a fork-lift, that will lift the container
from below, apllying a load in the lower part of the structure and in the
steel floor as well, as image below:
A report must be sent at the end, containing the detailed results and
analysis methods applied.
PDF files:
● https://drive.google.com/open?id=1LOVxrVcfV8XL5-q_8h2pim
f3WgxF1Sfy (sheet #1)
● https://drive.google.com/open?id=1RQ20N_UAizANMA4CJG7
VlcS1AbQQjgWQ (sheet #2)
Revit Model:
● https://drive.google.com/open?id=1Yx3QNz2KH3RzoV2aks7w
oD3rY_IQY4TV (Revit 2020 was used)
Current drawings
Tasks
1. Static analysis (hold self structure and a 600kg equipment inside
of the container)
2. Simulate structure lifting by a crane
3. Simulate structure lifting by a forklift
Requisites
● Revit
● Mechanical or Civil Engineering
● SolidWorks
● Any steel Analysis software
ㅡ
Development/Tasks
● Open the Revit file with the steel structure on SolidWorks
● Insert the loads
● Simulate and test the loads applied to the Model
● Take some prints of the loads and simulation
● Take some pictures of the load test, like an assemble manual
● Write a report explaining the results
Deliverables
● Solidworks model editable files
● Results report (.pdf)
ㅡ
Example of the result expected:
Quality