FEATURES & BENEFITS General purpose, cost effective silicone adhesive/sealant
• One-component adhesive/sealant • Cures at room temperature when APPLICATIONS exposed to moisture in the air • General industrial sealing and bonding applications • Acetoxy cure system • Glaze and waterproof for Windows •Doors •Shopfronts •Internal fixtures and • Non-sag, paste consistency fittings •Skylights • Easy to use/ease of application compared to non-silicone materials TYPICAL PROPERTIES • Cures to a tough, flexible rubber Specification Writers: These values are not intended for use in preparing • Resistant/outstanding resistance to specifications. ozone, UV, moisture and temperature extremes Property Unit Result • Good adhesion to glass Available Colors Aluminum, Clear, • Stable and flexible from -40ºC to Black, Bronze, Gray, Light Gray, White +150ºC <As supplied> Flow, sag or slump mm <2 Extrusion rate1 g/min 779 Tack-free time min 11 In depth cure at 25°C/50%RH for 1 day mm 1.6 <As cured 7 days at 25°C/50%RH> Density g/cm3 0.97 Durometer hardness, Shore A 17 Tensile strength MPa 1.4 Elongation at break % 550 1 Extrusion rate: 3.2 mm orifice at 0.62 MPa.
HOW TO USE HANDLING PRECAUTIONS
Substrate Preparation PRODUCT SAFETY All surfaces must be clean and dry INFORMATION REQUIRED FOR degrease and wash off any SAFE USE IS NOT INCLUDED IN contaminants that could impair THIS DOCUMENT. BEFORE adhesion. Suitable solvents include HANDLING, READ PRODUCT AND isopropyl alcohol, acetone or methyl SAFETY DATA SHEETS AND ethyl ketone. CONTAINER LABELS FOR SAFE USE, PHYSICAL AND HEALTH A primer may be needed for optimum HAZARD INFORMATION. THE adhesion to some substrates based on SAFETY DATA SHEET IS testing conducted by the end user. AVAILABLE ON THE DOW WEBSITE AT WWW.CONSUMER.DOW.COM, OR FROM YOUR DOW SALES APPLICATION ENGINEER, OR DISTRIBUTOR, OR BY CALLING DOW CUSTOMER SERVICE. USABLE LIFE AND • Cannot be painted, as paint will not regulatory compliance specialists STORAGE adhere to sealant. available in each area. Product should be stored at or below • Not recommended for use on plastic 32°C (90°F) in original, unopened sheeting. For further information, please see our containers. The most up-to-date shelf • Not for use on freshly painted website, www.consumer.dow.com or life information can be found on the surfaces (enamel or solvent- consult your local Dow representative. XIAMETER Web site in the Product containing types). Detail page under Sales Specification. • Should not be applied to materials LIMITED WARRANTY that bleed plasticizers or solvents or INFORMATION – PLEASE As DOWSIL™ GP Sealant cures by release by-products that may inhibit READ CAREFULLY reaction with moisture in air, keep the cure, affect adhesion or discolor the The information contained herein is container tightly sealed when not in sealant (e.g. bituminous-based offered in good faith and is believed to use. A plug of used material may form adhesives and coatings). be accurate. However, because in the tip of a tube or cartridge during • Do not clean or treat the sealant with conditions and methods of use of our storage. This is easily removed and materials, solvents or cleaning products are beyond our control, this does not affect the remaining contents. agents that may affect or discolor the information should not be used in sealant, particularly during sealant substitution for customer’s tests to LIMITATIONS cure. ensure that our products are safe, This product is neither tested nor • Do not apply at temperatures below effective, and fully satisfactory for the represented as suitable for medical or 4°C or when substrate surface intended end use. Suggestions of use pharmaceutical uses. temperatures exceed 50°C. shall not be taken as inducements to • Should not be used as an interior infringe any patent. DOWSIL GP Sealant is not penetration fire stop sealing system. recommended: • Should not be applied to surfaces in Dow’s sole warranty is that our direct contact with food or drinking products will meet the sales • Do not use for structural glazing. water. This sealant has not been specifications in effect at the time of • Not recommended for continuous tested to determine status under U.S. shipment. water immersion applications. Food and Drug Administration regulations. • Not recommended for use with Your exclusive remedy for breach of marble and similar highly porous • Not recommended for direct contact such warranty is limited to refund of stone finishes whose appearance on the reflective coatings of mirrors. purchase price or replacement of any may be affected by sealant. • Polyester powder coat paint exhibits product shown to be other than as • Not recommended for use on a highly variable wax content on the warranted. materials where the cure by-product surface. Ensure thorough solvent (acetic acid vapor) may cause cleaning. TO THE FULLEST EXTENT corrosion or discoloration or where • Sealant cures by contact with PERMITTED BY APPLICABLE the sealant may affect their moisture vapor in the air. Not LAW, DOW SPECIFICALLY appearance (e.g. galvanized iron, recommended for use in closed or DISCLAIMS ANY OTHER copper, brass, zinc coated steel and confined areas where sealant cure EXPRESS OR IMPLIED other metals; or concrete, cement, may be inhibited by lack of air. WARRANTY OF FITNESS FOR A brick, limestone, marble and similar • Do not use in the manufacture of PARTICULAR PURPOSE OR highly porous stone finishes). insulated glass (IG) units. MERCHANTABILITY. • Not recommended for expansion joints where high movement is HEALTH AND DOW DISCLAIMS LIABILITY expected. ENVIRONMENTAL FOR ANY INCIDENTAL OR • Not recommended for use in below- INFORMATION CONSEQUENTIAL DAMAGES. ground joints or trafficable joints To support customers in their product where abrasion and physical abuse www.consumer.dow.com safety needs, Dow has an extensive are encountered. Product Stewardship organization and • Not recommended for use in the a team of product safety and construction or sealing of aquariums.