Professional Documents
Culture Documents
Contents
I Scope ................................................................ 2
II Conflicts and Deviations ................................... 2
III References........................................................ 2
IV Modifications to Process Industry Practice
PIP ARS08390 .................................................. 3
Revision Summary................................................... 4
I Scope
This specification defines the minimum requirements for blast resistant doors and
frames. The Process Industry Practice PIP ARS08390 “Blast Resistant Doors, Frames,
and Related Hardware Specification” dated June 2013 in its entirety, except as modified
by this specification, shall constitute the basis of this specification. .
Any conflicts between this document and other applicable Mandatory Saudi Aramco
Engineering Requirements (MSAERs) shall be addressed to the EK&RD Coordinator.
Any deviation from the requirements herein shall follow internal company procedure
SAEP-302.
III References
The selection of material and equipment, and the design, fabrication, construction,
maintenance, and repair of equipment and facilities covered by this specification shall
comply with the latest edition of the references listed below, unless otherwise noted.
The following paragraph numbers refer to Process Industry Practice PIP ARS08390 dated
June 2013, which is part of this specification. The text in each paragraph is an addition,
exception, modification, or deletion to PIP ARS08390 as noted. Paragraph numbers not
appearing in PIP ARS08390 are new paragraphs to be inserted in numerical order.
(Addition) Add ASTM F 2927 -Door Systems Subject to Air blast Loadings
(Modification and Deletion) Delete the reference to NFPA 101 - Life Safety
Code. Add a bullet-point reference for SAES-M-100
2.3 (Deletion) Delete the entire reference to DOJ, DOL, and ADA requirements.
4.2.2.4.A.1 (Deletion) Delete the statement “registered in the locality where the blast
door(s) is to be installed.”
4.2.2.6 (Addition) Add at the end of the paragraph “for fire rated offshore blast
resistance doors and frame shall follow SOLAS-1974 and IMO FTP Code
requirement.”
4.2.2.7 (Addition) Add at the end of the paragraph “or ASTM F2927.”
4.5.1 (Modification) Revise the paragraph to read as follows “Blast resistant doors
shall be designed for the dynamic loads furnished in Blast Design
Requirements (BDR) Data Sheet (found in SAES-M-009, Appendix A).”
4.6.1.6 (Addition) Add at the end of the paragraph “the oversized door shall meet
the requirement of SAES-M-100, Paragraph 715.4.6.2.”
4.6.1.8 (Modification and Addition) Change G60 with “G90”. Add at the end of the
paragraph “or plate in accordance with ASTM A36/A36M and galvanized in
accordance with ASTM A123/A123M.”
4.6.2.2 (Modification and Addition) Change G60 with “G90”. Add at the end of the
paragraph “or plate in accordance with ASTM A36/A36M and galvanized in
accordance with ASTM A123/A123M.”
4.8 (Addition) Add New Paragraph 4.8.5 “Only shop coating shall be allowed.
Field coating is not allowed on site except as allowed by paragraph 4.8.4”.
Revision Summary
15 December 2012 New Saudi Aramco Materials System Specification.
17 July 2017 Major revision and overlaid on the Process Industry Practice PIP ARS08390 “Blast
Resistant Doors, Frames, and Related Hardware Specification “dated June 2013.”