Professional Documents
Culture Documents
Adjust Position Sensor Chuck NDS: 15.03.2016 Hrahn
Adjust Position Sensor Chuck NDS: 15.03.2016 Hrahn
15.03.2016 HRahn
Seite 1 von 6
JAGENBERG-GRUPPE
Seite 2 von 6
JAGENBERG-GRUPPE
Point 1 is to teach the Sensor. This Function must not be used !!!
Point 3 is to Reset the measurement range to Factory Setting. Output selection is not
reset by Factory Setting Function
Seite 3 von 6
JAGENBERG-GRUPPE
When the Sensor is set these Values must be shown in HMI and can be varified by
measuring tape:
235mm from Turret Disc to black Part Chuck Head means 0mm displayed
Seite 4 von 6
JAGENBERG-GRUPPE
471mm from Turret Disc to black Part Chuck Head means -237mm displayed.
Seite 5 von 6
JAGENBERG-GRUPPE
The Position is scaled in FC901 for Winder A and FC1101 for Winder B
The Values at X1 to Y2 must not be changed!!!
Seite 6 von 6