Professional Documents
Culture Documents
College of Engineering
ELECTRONICS ENGINEERING DEPARTMENT
Submitted by:
I. OBJECTIVES
3-5 pcs assorted (used &new and different types) coils and transformers.
Multi-tester (VOM/DMM)
III. SET-UP
Draw/show the scenario of testing a coil and transformers using a multi-tester. You
may capture a picture showing the same.
IV. PROCEDURES
1. Determine the terminal leads (primary and secondary) of at least five different types of
coils and transformers.
2. Identify the type and rating (e.g. stepdown transformer: primary: 220V, secondary:
110V; isolation transformer: primary and secondary both 220V; stepdown transformer
multi output: primary 220V, 110V and secondary: 12V, 9V, 6V, 3V ), and so on.
3. Test the coils and transformers if good or bad.
4. Fill-up table in V.
V. SAMPLE DATA FOR YOUR REFERENCE
VI. QUESTIONS
VII. RECOMMENDATIONS/REACTIONS/CONCLUSION