API 653 Third Edition No. QUESTION CODE CLAUSE 1 Calculate the t min. welded tank shell API653 4.3.3.1 2 What is the maximum allowable stress for bottom & second API653 4.3.3.1 course 3. To change the service of the tank to above 200°F what API653 4.2.4.4 requirements are to be met 4. What is the maximum allowable stress for reconstructed tank API653 4.3.3.1 5. What is the maximum allowable stress for revited tank API653 4.3.4.1 6. Annular bottom plate thickness (Sp. Gr. < 1.0) API653 Table 4-4 7. Assessment of the safe use of a tank constructed of unknown API653 Fig. 5.2 materials 8. What records shall be maintained by the Owner / Operator API653 6.8.1 9. What are the material specifications for structural materials API653 7.3.2 10. Shell design for a reconstructed tank, with materials whose allowable stresses are not given in Table 3-2 of API 650, what API653 8.4.2 allowable stresses are to be taken 11. After the valve has been installed on the flange at what pressure API653 9.14.5.3 the pressure test shall be performed 12. In tank re-construction, new vertical joints in adjacent shell API653 10.4.2.1 courses shall be offset by what minimum distance 13. During tank reconstruction / repair what is the maximum allowed API653 10.4.2.5 undercutting for vertical joints 14. What is the maximum reinforcement allowed for horizontal joint API653 Table 10-1 of ¾” plate 15. In completed horizontal butt joints, the upper plate shall not API653 10.4.4.2 project beyond the lower plate by how much 16. Calculation of Internal Bottom settlement or bulges API653 B.3.3 17. Problem on edge settlement API653 Fig B-10 18. For welding A516 Gr 70 materials what electrode classification API650 2.8 shall be used