Professional Documents
Culture Documents
Fuel System > Troubleshooting > P0012 \'A\' Camshaft Position-Timing Over-Retarded (Bank 1)
COMPONENT LOCATION
GENERAL DESCRIPTION
Different from the existing fixed cam phase angle type, CVVT(Continuously Variable Valve Timing) is the device
which varies cam phase angle continuously to be optimum. And with engine oil pressure, it operates. CVVT consists
of OCV(Oil Control Valve) and cam phaser. OCV, mounted on cylinder head, controlls the amount and direction of
oil delivered to cam phaser by oil valve which is connected to a solenoid. Cam phaser, rotating cam phaser rotor
with pressure and amount of oil produced by OCV, rotates cam shaft forcefully for or against the rotating direction
and finally, cam shaft phase changes. With the appliance of CVVT, engine power,fuel efficiency and the quality of
exhaust gas are improved.
DTC DESCRIPTION
If "Counter of Δ (original target - actual angle) > 3 Deg" is over 10 times under enable conditions, ECM/PCM sets
DTC P0012.
SPECIFICATION
ITEM SPECIFICATION
6.9 ~ 7.9Ω at 20°C
Coil Resistance (Ω)
(68°F)
SCHEMATIC DIAGRAM
(A/T)
Page 64 of 753
(M/T)
Fault is intermittent caused by poor contact in the sensor’s and/or ECM’s connector or was repaired and
ECM/PCM memory was not cleared. Thoroughly check connectors for looseness, poor connection, bending,
corrosion, contamination, eterioration, or damage. Repair or replace as necessary and go to "Verification of
vehicle Repair" procedure.
SYSTEM INSPECTION
1. Visual check.
(1) Check engine oil gauge.
(2) Check contamination of engine oil.
(3) Check contamination of OCV filter.
(4) Check clog of oil path.
(5) Is there any problem?
COMPONENT INSPECTION
Page 66 of 753
1. Check OCV
(1) Connect scantool to Data Link Connector(DLC).
(2) Key "ON".
(3) Perform "Actuation Test" for OCV.
Substitute with a known-good CVVT and check for proper operation. If the problem is corrected, replace
CVVT and then go to "Verification of Vehicle Repair" procedure.
Substitute with a known-good OCV and check for proper operation. If the problem is corrected, replace
OCV and then go to "Verification of Vehicle Repair" procedure.
Fuel System > Troubleshooting > P0016 Crankshaft Position–Camshaft Position Correlation (Bank 1
Sensor A)
COMPONENT LOCATION