Professional Documents
Culture Documents
Reference of Surface Preparation and Coating Application
Reference of Surface Preparation and Coating Application
Photograph showing
condition of WBT after
power tool cleaned to ISO St
3
(Please make sure that you have 3 pictures in each page. If you
don't fill in the full PH report then make sure the last page has 3
photos in order not to have an empty photo space)
Photo No. 1
Photograph showing
condition of WBT after
power tool cleaned to ISO St
3.
Note: overlap areas were
roughen / abraded to have a
proper adhesion of fresh
applied coatings.
Photo No. 2
Photograph showing
condition of WBT after
power tool cleaned to ISO St
3.
Note: overlap areas were
roughen / abraded to have a
proper adhesion of fresh
applied coatings.
Photo No. 3
Photo No. 4
Photograph showing after
1st TU application of
SigmaCover 280 Yellow
Green on WBT.
Note: Overlap the
application of coatings on
powertooled areas.
Photo No. 5
Photograph showing after
2nd TU application of
SigmaCover 280 Grey on
WBT.