This lab report document contains instructions for an experiment on LCR circuits. The experiment involves making measurements of voltage and current in LR circuits with varying frequency, and LCR circuits with varying frequency. The student is instructed to fill out 4 tables with their measurements and calculations of impedance, voltage, current, and phase for the LR and LCR circuits. They are also instructed to draw a phasor diagram for the LCR circuit.
This lab report document contains instructions for an experiment on LCR circuits. The experiment involves making measurements of voltage and current in LR circuits with varying frequency, and LCR circuits with varying frequency. The student is instructed to fill out 4 tables with their measurements and calculations of impedance, voltage, current, and phase for the LR and LCR circuits. They are also instructed to draw a phasor diagram for the LCR circuit.
This lab report document contains instructions for an experiment on LCR circuits. The experiment involves making measurements of voltage and current in LR circuits with varying frequency, and LCR circuits with varying frequency. The student is instructed to fill out 4 tables with their measurements and calculations of impedance, voltage, current, and phase for the LR and LCR circuits. They are also instructed to draw a phasor diagram for the LCR circuit.
Lab Report REMINDER: Units of Xc, XL, XTOTAL and ZTOTAL are Ohms Show sample calculations including all units below or on another sheet.
Part I. Table I. LR Circuit, Vary Frequency
Fill in the following table. REMEMBER TO WRITE ALL UNITS.
R = L=
RMS VALUES CALCULATE
Run % Dis- f VLR = VLR = # ϕRC = crepancy (hz) VL VR VOUT √(VR2+VL2) tan-1(VL/VR) in VLR
1 2000
2 6000
Part II. Table II. LCR Circuit
Fill in the following table. REMEMBER TO WRITE ALL UNITS. Show calculations below or on a separate sheet for calculated values.
R = C = L=
RMS VALUES CALCULATE
f ZTOTAL= VLCR = VLCR = I = VR % Discrepancy (hz) VL VC VR VLCR √(VR2+(VL-VC)2) VOUT R in VLCR I Part II. PHASOR DIAGRAM Draw the phasor diagram for this LCR circuit on this graph. Label your axes and include VL, VC, and VR.
Measure the graphical value of VLCR and
find the discrepancy between your measurement and the measured value of VOUT.
Part II. Table III. IMPEDANCE CALCULATIONS
Fill in the following table. REMEMBER TO WRITE ALL UNITS. Show calculations below or on a separate sheet.