Professional Documents
Culture Documents
Wire ways are units of assembly of troughs used for housing and protecting electric wire and cable and in which
conductors are laid in place after the wire way has been installed as a complete system.
Provisions for Metal Wire Ways
1. No conductor larger than that for which the wire way is designed shall be installed in any wire way.
2. Shall not contain more than 30 current carrying conductors at any cross section.
3. Where insulated conductors are defected within the wire way of greater than 30 degrees.
4. Splices and top shall be permitted within a wire way provided.
5. Dead end of wire way shall be closed.
6. Extensions from wire ways shall be made with cord pendants.
7. Wire ways shall be marked so that their manufacturers name or trademark will be visible after installation.
8. Grounding shall be in accordance with the provision of Article 2.50 of PEC.
Development (Time Frame: Day 2)
Learning Task 1
Answer the following questions base on the provision on metallic and non-metallic wire ways. Write your answers on your
answer sheet or work sheet notebook.
1. Why extensions from wire ways shall be made with cord pedants?
_________________________________________________________________________________________________________________
_________________________________________________________________________________________________________________
_________________________________________________________________________________________________________________
2. What is grounding provisions stated in article 2.50 of PEC?
_________________________________________________________________________________________________________________
_________________________________________________________________________________________________________________
_________________________________________________________________________________________________________________
3. What does it mean “It any hazardous location, except as permitted”?
_________________________________________________________________________________________________________________
_________________________________________________________________________________________________________________
_________________________________________________________________________________________________________________
4. Why carrying conductors in any cross section shall not contain more than 30 ampere current?
_________________________________________________________________________________________________________________
_________________________________________________________________________________________________________________
_________________________________________________________________________________________________________________
Wire ways and cable troughs are designed to protect electrical wires from dust, dirt, water and oil. They are available in
various styles, sizes and fittings for use for wide range of voltages. They are often used to house and protect power and
communications cables for commercial, institutional, industrial and utility needs. These wire way systems consist of wire way and
appropriate fittings to complete the installation per the electrical drawings. Electrical wire ways are often furnished with polyester
powder coat paints. They are available with factory installed dividers to separate power and low voltage wiring housed in the
same wire way sections. The material thickness is based on wire way dimensions according to requirements. The base and cover
of wire ways are factory assembled and fitted with wing nuts and screws for positive latching. Some wire way bases are provided
with electrical knockouts. They are available with spectrum dimensions like wide and deepness.
Learning Task 2
Answer the questions elaborately on wire ways discussion. Write your answers on your answer sheet or work sheet
notebook.
2. Why must style, sizes and fittings of wire ways highly consider for place of installation?
_________________________________________________________________________________________________________________
_________________________________________________________________________________________________________________
Learning Task 3
Give the description of the materials/components for wire ways. Write your answers on your answer sheet or work sheet
notebook.
Wire ways materials/components Description
1. Closing plates
2. Telescopic fittings
3. Reducer
4. Cut off fittings
5. Partitions
6. Transposition section
7. Nipples
8. Transposition elbows
9. Swivel fittings
10. Panel adapter
11. Drop hanger
12. Across
13. Tee fittings
14. Straight lengths
15. Captive joint connector
2. Non Metallic Wire Ways – are flame retardant, non-metallic through with removable covers for housing and protecting
electric wire and cables in which conductors are laid in place after the wire way has been installed as a complete system.
Installer should have the familiarity over those material or components that will be needing. There must be the right
choice of materials base on the provision given by the authority so that hazards, and back job will be avoided.
Learning Task 4
Illustrate the material below. Utilizing of any software and apps in illustration is highly encourage. Insert your printed output
in your answer sheet or work sheet notebook.
Learning Task 5
Make a system layout of wire ways utilizing all the components in installation. Using of any software and apps in illustration
is highly encourage. Insert your printed output in your answer sheet or work sheet notebook.
Fill in the blank with a word or group of words that will make the statement complete. Write your answer on a separate
answer sheet.