Professional Documents
Culture Documents
ARTICLE RS-1
CONTENTS, METHODS, AND MEANS OF MARKING
110
--`,,```,,,,````-`-`,,`,,`,`,,`---
Authorization for the use of the Code RP symbol. Except stress” stamps, but the other required data may be
when the nameplate is to be molded in, the Code symbol stamped, etched, cast, or impressed thereon. Alterna-
shall be applied by the Manufacturer only with the accept- tively, the other data may be printed or engraved on a
ance of the Inspector after the hydrostatic or pneumatic suitable material and then be molded as an integral part
leakage test for Class I vessels and the acoustic emission of the vessel to serve as a nameplate. The arrangement
Acceptance Test for Class II vessels has been satisfacto- of the data shall be substantially as shown in Fig. RS-
rily made and any other required inspection and testing 132.1.
have been satisfactorily completed. Such application of
the Code symbol together with final certification in accor- NOTE: The maximum allowable pressure must be equal to or less
dance with the rules of this Section shall confirm that than the design pressure. The maximum allowable temperature must
be equal to or less than the maximum design temperature. The minimum
all applicable requirements of this Section have been
allowable temperature must be equal to or greater than the minimum
fulfilled. design temperature.
111
--`,,```,,,,````-`-`,,`,,`,`,,`---
FIG. RS-132.1 FORM OF STAMPING AND MARKING FIG. RS-132.1M FORM OF STAMPING AND
MARKING
112
--`,,```,,,,````-`-`,,`,,`,`,,`---
113
RS-300 FABRICATOR’S DATA REPORTS finished vessel. These Partial Data Reports, together with
his own inspection, shall be the final Inspector’s authority
A Fabricator’s Data Report shall be filled out on Form
to authorize and witness the application of a Code symbol
RP-1 or RP-3, as applicable (sample forms are included
to the finished vessel (see RS-110). Sample Data Report
at the end of this Section), by the Fabricator and shall
Forms RP-2 and RP-4 are included at the end of this
be signed by the Fabricator and the Authorized Inspector
Section.
for each pressure vessel.
114
--`,,```,,,,````-`-`,,`,,`,`,,`---