Professional Documents
Culture Documents
Unit Test No.1: Controls Engineering
Unit Test No.1: Controls Engineering
1
CONTROLS ENGINEERING
Name: Date:
I. Terminology Identification. Write the answer on the blank space provided.
_______________ 1. This is the ability of any system to provide a bounded output when a bounded input is
applied to it.
_______________ 2. Is the device that changes the value of the manipulated variable.
_______________ 3. the system does not measure the actual output and there is no correction to make the
actual output.
_______________ 4. are binary signals which has only two possible states. Either 1 or 0, True or False, On or
Off.
_______________ 5. Is a contact that does not flow current in its normal state. Energizing it and switching it
on will close the contact, causing it to allow current flow.
_______________ 7. The emitter and the receiver are located in the housing of sensor.
_______________ 8. Are used in hydraulic circuits, these valves would stop or remove the flow of the pump
back to the tank when the machine is not operating. so by this reduction of heat and energy saving can be
achieved because the prime mover load is reduced.
_______________ 9. The thermistor is a primary element that is very similar to the RTD. It, too, is based on
the theory that the resistance of a material increases or decreases with a change in temperature.
_______________ 10. This infrared image is created using a tiny grid of infrared detectors inside the
thermal imaging camera behind a lens.
II. Part Identification. Write the answer on the black space provided.
A. PLC Parts
1. ___________
2. ___________
3. ___________
6. __________
III. Enumeration
A. 5 Types of Pressure Control Valves
B. Give 5 Temperature Sensors or measuring devices
C. 3 Types of Photoelectric Sensors
D. 2 Types of Encoders
E. 5 Types of PLC Programming Languages
F. 3 Capabilities of Modern PLC