Professional Documents
Culture Documents
S.Y. 2021-2022
TLE 9
GRADE 9 – COLOSSIANS
General Direction: This is a 50-item test, read each direction written in each type of test,
answer this test in one hour. Avoid erasures.
I. Identification. (1-10)
Direction. Identify the appropriate tool to use for each of the following:
___________1. It is used to equalize the electrical charge between you and the equipment when
repairing a computer.
___________2. You will use this type of screwdriver with crosshead screws.
___________3. Turn the screwdriver _______ to loosen the screw
___________4. Turn the screwdriver clockwise to _____ the screw
___________5. Before cleaning any device, you will turn it off and ______ the device from the power
source.
___________6. Clean the contacts on components with ____________.
___________7. It is used to retrieve parts that may be hard to reach by your fingers
___________8. Use a __________ when you are working with a slotted screw
___________9. Pencils should not be used inside the computer to change the setting of switches or
to pry off jumpers because the tip contains _____ which can act as a conductor and may damage the
computer components.
___________10. When compressed air is used to clean inside the computer, the air should be blown
around the components with a minimum distance of _____ inches from the nozzle.
Page | 1
TLE 10
Cleaning Tools Diagnostic Tools
28-29)
30-31)
32-33)
34-35)
_____36. Keep the work area clean, tidy, well swept/washed, and well lit; floors should be level and
have a non-slip surface.
_____37. Do not leave machines unattended: turn the power off.
_____38 Check and adjust some safety devices only before each job.
_____39. Keep hands away from the cutting head and all moving parts.
_____40. Do not return all portable tooling to their proper storage place after use.
_____41. In selecting the best tools for each task, requires training in the proper use of it.
_____42. You should follow the manufacturer’s guidance and instructions for the specific tool.
_____43. It is not good to avoid distracting an operator; horseplay cannot lead to injuries.
_____44. In selecting the best tool, we should first know and understand in detail the scope of work to
be accomplished.
_____45. In selecting the best tool, we should first know and understand in detail the scope of work to
be accomplished.
_____46 Follow lock-out procedures after measuring, cleaning or making any adjustments
_____47. In selecting the best tool, we should first know and understand in detail the scope of work
to be accomplished.
_____48. In selecting the best tool, we should first know and understand in detail the scope of work to
be accomplished.
_____49. In selecting the best tool, we should first know and understand in detail the scope of work to
be accomplished.
_____50. Wear loose clothing, gloves, necktie, and other jewelries while working with machines.
3
The LORD is more pleased when we do what is right and just than when we offer him sacrifices.
− Proverbs 21:3 NLT
Prepared by:
Page | 2
TLE 10