Professional Documents
Culture Documents
Pt 3.
- Minor Project.
Looked at adding in the water tank, to do this I created
a polygon cube and smoothed its geometry to create a
sphere. From there I then applied a lattice deformer
and pulled the sphere into to roughly the shape I was
looking for, adding in extra edge loops where needed
and removing faces where they can’t be seen.
Final Water
Tank.
Adding On The Antenna.
After adding in the antenna I then looked at creating the front
port flap.
To do this I created a cube and then went about shaping
the flap to match that seen in the orthographs. Staring by
modeling half and then mirroring later.
Here I also added in a rivet hole using the circularize tool
and extruding, ready for when I add in the connecting wires
to complete the flap.
I then mirrored the half flap. To fix the
part where the flap curves away from the
drones surface I used a lattice deformer
to help bring in the geometry back in.
Here I also did some clean up to the
geometry by removing some of the edges
loops to help with some of the pinching
and dips within the surface.
I then looked to add in the rivets for
the other side of the connecting wire. To
do this I duplicated the flap and deleted
any geometry that wasn’t needed and
adjusted the new rivets as needed.
Creating the Connecting Wires for the Flap.
From there I proceeded to add in the three light
strips to the front of the drone . To do this I
added in some extra edge loops and extruded
the faces in and then back to in set the lights
into the mesh.
From there I added in three curved piece of
geometry for the lights and inlaid them to the
drones geometry.
Front of Drone
Outcome.
I then added in the responder tubes, initially starting with
a cube and shaping the geometry to form the first half of
the tubes. Once happy with the geometry I then mirrored
the first responder tube across. From there they were put
into place and had a lattice deformer applied to help
curve them to the top of the drone.
I then proceed to add in little details to each tube to
help add a level of interest as seen the in concept art for
each drone.