Professional Documents
Culture Documents
Instructions
Write a full data commentary of your chosen table of chart.
Response:
COLLEGE OF ENGINEERING
University Site, Red-V, Lucena City, Philippines; Tel No. (042)717-0162
Manuel S. Enverga University Foundation
Lucena City, Philippines
Granted Autonomous Status
In reference to the table above this is all about the load standard which being used on the
continuity. members shall be designed using the loading motions, which would cause
Every floor shall be designed for the unit live loads as set forth on the table above.
These loads shall be taken as the minimum live loads of horizontal projection to be used
in the design of building for the occupancies listed, and loads at least shall be assumed
for uses not listed in this section but that creates or accommodates similar loadings.
Live loads can be determined in designing floors that the actual live load will be
greater than the value shown in the table, the actual live load shall be used in the design
COLLEGE OF ENGINEERING
University Site, Red-V, Lucena City, Philippines; Tel No. (042)717-0162
Manuel S. Enverga University Foundation
Lucena City, Philippines
Granted Autonomous Status
of such buildings or portions thereof. Special provisions shall be made for machine and
apparatus loads.
Distribution of uniform floor loads are involved, consideration may have limited to
foil dead load on all spans in combination with full live load on adjacent spans and
alternate spans. Floors shall be designed to support safely the uniformly distributed live
loads prescribed in this section or the concentrated load given in table whichever
produces the greatest load effects. Unless otherwise specified the indicated concentration
shall be assumed to be uniformly distributed over an area 750-mm square and shall be
Provision shall be made in areas where vehicles are used or stored for
concentrated loads, L, consisting of two or more loads spaced 1.5m nominally on center
without uniform live loads. Each load shall be 40 percent of the gross weight of the
maximum size vehicle to be accommodated. Parking garages for the storage of private
or pleasure-type motor vehicles with no repair or refueling shall have a floor system
designed for a concentrated load of not less than 9 kN acting on an area of 0.015 mm
without uniform live loads. The condition of concentrated or uniform live load, combined
in accordance with this section as appropriate, producing the greatest stresses shall
govern.
COLLEGE OF ENGINEERING
University Site, Red-V, Lucena City, Philippines; Tel No. (042)717-0162