Professional Documents
Culture Documents
1. Figure 1 below shows a built-up beam made of A36 steel with Fy = 248 Mpa. The flanges
are continuously connected to the web by means of fillet welds. The beam has 10 meters
span and is simply supported at its ends, with additional lateral support at its midspan
(i.e. unbraced length is half the span). Using formula in handouts, answer all the
following questions.
Figure 1:
20mm
20mm 525mm
20mm
400mm
f) Computing for Lp, is the actual unbraced length of the beam Lb less than Lp ? (3 pts.)
g) Considering the computed Lp in the previous question and assuming Lr = 15.0 m , what
is the nominal flexural strength of the beam? Use Cb = 1.0. (5 pts.)
note: No need to compute for Lr , just assume Lr = 15.0 m.
Figure 2:
1500 kN 1500 kN W 530x138:
k1 = 27.5mm
k = 40.2mm
tw=14.7mm
k1
B N
a. What is your design dimension for the bearing length N of the beam bearing plate?
Round-off your design dimension to the nearest safe 5 mm. (5 pts.)
b. What is your design dimension for the bearing width B of the beam bearing plate?
Round-off your design dimension to the nearest safe 5 mm. (5 pts.)
c) What is your design dimension for the thickness t of the beam bearing plate?
Round-off your design dimension to the nearest 5 mm. (5 pts.)
3. Figure 3 below shows a W530 x 201 beam reinforced by cover plates at its top and bottom
flanges. The width of the cover plate is fixed at 300mm. The beam is simply supported over
a span of 8m and carries a uniformly distributed load of 260kN/m, including its weight. The
capacity of each shear connector is 30kN. Use Fy = 248 Mpa and Fb = 0.60Fy. For W530 x
201, bf = 319.40mm, d = 585mm., Ix = 2.21 x 109 mm4, Sx = 7,556,000 mm3,
Answer the following questions. (15 pts.)
Figure 3: 300mm
260 kN/m
W 530x201
585mm
8m
a) What is your design dimension of the cover plates’ thickness? Round-off dimension to the
nearest safe 5 mm. (6 pts)
Note. Be sure to check that the elastic section modulus of the beam section with your designed
cover plates is nearly equal but greater than the required section modulus.
b) What is the required spacing of the shear connectors 1.0 m. from the support.
Hint: Obtain first the shear V at 1.0 m. from the support. (5 pts.)