Professional Documents
Culture Documents
SAEX 4
1.A force of 200 lbf acts on a block at an angle of 28° with respect to horizontal. The block is pushed 2 ft horizontally. The work done
by this force is most nearly *
480 J 540 J
320 J 210 J
2.A plumb bob hangs from the roof of a railroad car. The car rounds a circular track of radius 300 m at speed of 90 kph. At what
angle relative to the vertical does the plumb bob hang? *
74 deg 12 deg
16 deg 78 deg
3.If the temperature of the medium is 0 deg C, what will the temperature be if it is doubled? *
4.A steel wire 10 m. long , hanging vertically supports a tensile load of 1000 N. Neglecting the weight of the wire, determine the
required diameter if the elongation is not to exceed 2.5 mm. Assume E = 200 GPa. *
5.How can relatively denser object be made to float on the less dense fluid? *
7.If equal and opposite forces applied to a body tend to elongate it, the stress so produced is called *
8.A rock of weight 10 N suspended by a string is lowered into water, displacing water of weight 3 N. Determine the tension in the
string. *
7N 13 N
3N 10 N
9.D’Alembert’s principle is used for *
10.A rubber band has an unstretched length of 180 mm. If it is stretched around a pole having a diameter of 60 mm, determine the
average normal strain in the band. *
0.0472 0.0263
0.0427 0.0236
Entropy Pressure
Volume Temperature
12.A heat exchange process in which the product of pressure and volume remains constant is known as *
13.The standard atmospheric pressure in meters of ammonia is (ρ = 600 kg/cu. m.) is : *
31 m 19 m
23 m 17 m
14.When comparing the momentum of two moving objects, which of the following is correct? *
The more massive object will have less momentum if its velocity is greater.
The object with the higher velocity will have less momentum if the masses are equal.
The less massive object will have less momentum if the velocities are the same.
The more massive object will have less momentum if the velocities are the same.
15.The center of gravity of the volume of the liquid displaced by an immersed body is called *
16.In any collision, which of the following is conserved: *
17.What is most nearly the effective annual interest rate on a loan if the nominal interest rate is 12%/yr compounded quarterly? *
11.8% 12.3%
12.0% 12.6%
18.When both are expressed in terms of SI base units, torque has the same units as *
19.Determine the modulus resilience for malleable cast iron: E = 165 GPa, normal stress = 230 MPa. *
280.5 160.7
250.8 170.6
20.The combined mass of car and passengers travelling at 72 km/hr is 1500 kg. Find the kinetic energy of this combined mass. *
21.Neglecting the change of gravity with elevation, estimate the speed of a satellite must have to orbit the earth at an elevation of
100 km. Earth's radius = 6,400 km. *
10,000
6,000 8,000
4,000
Prepared by: HAROLD L. BALMES
LEGIT MULTIVECTOR Review and Training Center
22.For a Newtonian fluid *
24.Coefficient of contraction is the ratio of *
loss of head in the orifice to the head of water available at the exit of the orifice
actual velocity of jet at vena contracta to the theoretical velocity
actual discharge through an orifice to the theoretical discharge
area of jet at vena contracta to the area of orifice
26.Water at a gauge pressure of 3.8 atm at street level flows into an office building at a speed of 0.6 m/s through a pipe 5.0 cm in
diameter. The pipes taper down to 2.6 cm in diameter by the top floor, 20 m above. Calculate the pressure on the top floor. *
27.The time it would take for a given sum of money to double at 4% per year simple interest is closest to: *
20 years 25 years
10 years 30 years
28.Air having an initial pressure of 14 psia, temperature of 80 deg F, and volume of 28.6 cu. ft. is compressed isentropically in a
nonflow process to a final pressure 120 psia. The final volume, in cu. ft. is nearest to *
3.7 15.5
6.2 12.1
29.The force of attraction of the Earth on a body. *
Mass Density
Weight Direction
30.A hallow shaft has an inner diameter of 0.035 m and an outer diameter of 0.06 m. Compute the torque if the shear stress is not
exceed 120 MPa. *
31.4 lbm/sec of steam enter a turbine with velocity of 65 ft/sec and enthalpy of 1350 BTU/lbm. The steam enters the condenser after
being expanded to 1075 BTU/lbm and 125 ft/sec. The total heat loss from the turbine casing is 50 BTU/sec. What power is
generated by the turbine? *
1600 hp 1700 hp
1400 hp 1500 hp
32.The cost of equipment is P 750,000 and the cost of installation is P 20,000. If the salvage value is 10% of the cost of equipment
at the end of 5 years, determine the book value at the end of the fourth year. Use straight line method. *
P 217,000 P 216,000
P 215,000 P 214,000
33.What is the type of annuity where the payments are made at the start of its period, beginning from the first period? *
34.Two equal forces act on a body. F₁ being due north and F₂ due east. To have a net force of zero, at what direction should F₃
act? *
SE NW
SW NE
35.The sum of strains in the three coordinate directions is known as *
Solution Dilution
Dilation Pilation
36.Longitudinal stress in a thin cylinder is *
37.The ability of the material to absorb energy in its elastic range. *
ductility strain
elasticity resilience
38.A deposit of P10,000 is made in a bank account that pays 8% interest compounded annually. How much money will be in the
account after one year? *
P10,900 P10,700
P10,600 P10,800
39.Thirty kilojoules of heat is removed from 1.4 kg of ice initially at −10 deg C. Its new temperature is *
40.Gross profit, sales less cost of goods sold, as a percentage of sales is called : *
41.What percentage of the human body will float in fresh water? Average density of human body is 980 kg/cu. m. *
4 2
98 96
42.The pressure of 100 kg of nitrogen (N₂) at 70°C in a 100-m³ tank is most nearly: *
Prepared by: HAROLD L. BALMES
LEGIT MULTIVECTOR Review and Training Center
43.A piece of iron has a weight of 3.5 N when it is in air and 2.0 N when it is submerged into water. What is the buoyant force on the
piece of iron? *
0.5 N 1.5 N
2.0 N 3.5 N
46.32 42.22
43.33 40.23
45.What is the book value of equipment purchased 3 yr ago for $15,000 if it is depreciated using the sum of years’ digits (SOYD)
method? The expected life is 5 yr. *
$9000 $4000
$6000 $3000
46.A person buys a piece of property for P100,000 downpayment and ten deferred semiannual payments of P8,000 each starting
three years from now. What is the present value of the investment if the rate of interest is 12 percent compounded semiannually? *
P148,500 P192,000
P144,000 P185,000
47.A market situation where there are few sellers and few buyers. *
48.A cycle is describes as follows. (1) The process from 1 to 2 is adiabatic, isentropic compression. (2) The process from 2 to 3 is
isobaric heat addition. (3) The process from 3 to 4 is adiabatic, isentropic expansion. (4) The process from 4 to 1 is constant volume
heat rejection. *
Diesel Carnot
Otto Rankine
impulse acceleration
momentum displacement
50.A water tank springs a leak from which emerges at 15 ft/s. The height of the water surface above the leak is *
1.9 ft 0.23 ft
3.5 ft 7.0 ft
SAEX 5
yellow green
blue red
2.For a logical circuit there are 'n' binary inputs. Then the number of different input combinations in the truth table is *
2n 2/n
2ⁿ 2(n + 1)
3.The Board of Electrical Engineering is empowered to look into the conditions affecting the practice of the electrical engineering
profession, adopt measures for the enhancement of the profession and maintenance of the high professional, technical and
__________ standards. *
ethical acceptable
U.S. theoretical
4.What is the chemical formula of ammonia? *
NH₃ NH₄
N₂H₃ N₃H₂
5.How are elements numbered numbered 90 to 103 in the periodic table called? *
6.What does UPS mean? *
7.The greatest negative number which can be stored in a computer that has 8-bit wordlength and uses 2's complement arithmetic
is *
−255 −128
−256 −127
8.BCD numbers are obtained *
9.A horizontal cord 5 m long has a mass of 2.5 grams. What must be the tension in the cord if the wavelength of a 120 Hz wave on it
is to be 50 cm? *
2.50 N 1.50 N
1.80 N 4.30 N
10.What occurs when two waves combine so that one subtracts from the other? *
Polarization Interference
Superposition Reinforcement
11.In a crystal structure, what is an interstitial atom? *
13.Convert 101101.11 (base 2) to the base 10 equivalent. *
42.25 45.75
52.35 48.68
14.Which of the following is not a fundamental rule in PEC? *
15.The minimum size of type IGS cable shall be _________. *
16.2's complement representation of a decimal number -4 is *
1010 0100
1100 1011
18.Steels that are used for axles, gears and similar parts requiring medium to high hardness and high strength are known as *
19.The most abundant rare gas in the atmosphere is *
Ar Ne
He Xe
20.The ore from which iron is obtained is *
bauxite taconite
chalcocite sphalerite
21.Which of the following is the strongest type of bond? *
covalent ionic
van der waals metallic
alkalinity acidity
presence of ions purity of the substance
23.Ability to resist deformation *
stability instability
steel stiffness
24.A source emits sound uniformly in all directions at a power level of 60 W. What is the intensity at a distance of 4 m from the
source? *
25.Wireways shall be supported at intervals NOT to exceed __________. *
26.In molecules of the same composition, variations of atomic arrangements is known as: *
27.The hardest form of carbon is *
charcoal diamond
coke graphite
28.How many different binary numbers can be stored in a register consisting of six switches? *
128 16
32 64
29.Maximum distance between 2 outlets in dwelling units. *
30.Transmission protocol serial asynchronous, 8 bits ASCII, 1 start, 1 stop, 1 parity bit, 9600 bps. How long will it take for 1 kilobyte
file to be transmitted thru the link? *
32.As the amount of slip increases, additional deformation becomes more difficult and it decreases until the plastic flow finally stops.
Slip may begin again only if a larger stress is applied. What is this phenomenon called? *
cooling crowding
twinning strain hardening
33.What is the speed of light through a glass whose index of refraction is 1.33? *
34.A light source emits a total luminous flux of 1000 lumens and distributed uniformly over 25% of a sphere. What is the luminous
intensity at 2.5-meter distance? *
35.A combination of AND function and NOT function results in *
inversion OR gate
NOR gate NAND gate
36.What is the color of the conductor used as a neutral? *
yellow orange
white green
37.Two-third of the atom in a molecule of water is hydrogen. What percentage weight of a water molecule if the weight of two
hydrogen atoms? The atomic weight of hydrogen is 1.008 g/mol and oxygen is 16.00 g/mole. *
19.11 19.12
11.19 12.19
38.What describes how to determine the number of service units that will minimize both customer's waiting time and cost of
service? *
39.Some of the principal factors that affect the operating temperature of a cable are the following EXCEPT one. Which one is this? *
40.Recognizable as suitable for the specific purpose , function, use, environment application, where described in a particular Code
requirement. *
Identified Approved
Labeled Listed
41.How many molecules are there in 25 g of hydrogen Chloride, HCI? *
42.What is JCPC in EPIRA stands for? *
44.Which one is NOT a requirement for the applicant to apply for registration as a registered electrical engineer? *
45.12₈, the equivalent decimal number is _____. *
12 20
100 10
46.How many members does the Board composed of? *
47.How far is the object from the image formed by a converging lens of focal length 50 cm, if the real image formed is 1.5 times
larger than the object? *
290.87 198.45
208.33 298.43
48.What is the angle of refraction of light as a beam of parallel light enters a block of ice at angle of incidence of 30°? The index of
refraction of ice is 1.31 and that of air is 1.0. *
30° 45°
22° 26°
49.What does PRBEE stands for? *
50.How many protons (P) and neutrons (N) are there in the nucleus are present in a Pb nucleus of atomic mass of 206? *
SAEX 5
1.A __________ is a device that merges several low speed transmission into high speed transmission. *
multiplexer server
voltage regulator mainframe
2.Calculate the force due to the pressure acting on the 1-m diameter horizontal hatch of a submarine submerged 600 m below the
surface. *
3.A car of mass m = 1000 slugs accelerates in 10 seconds from rest at a constant rate to a speed of v = 20 ft/sec. What is the
resultant force on the car due to this acceleration? *
5.When a pressure of 2.0 MPa is applied to a sample of kerosene, it contracts by 0.15%. The bulk modulus of kerosene is: *
6.Which of the following is correct: *
7.The first cost of a machine is P1,800,000 with a salvage value of P300,000 at the end of 5 yrs. Determine the book value after 3
years using SOYD method. *
P750,000 P700,000
P500,000 P600,000
8.The weakest section of a diamond riveting, is the section which passes through *
9.A projectile leaves a velocity of 50 m/s at an angle of 30 degrees with the horizontal. Find the maximum height that it could
reach. *
31.86 m 51.26 m
28.46 m 41.26 m
10.The slope on the road surface generally provided on the curves is known as *
12.The present worth of cost associated with an asset for an infinite period of time is referred as: *
13.The thermodynamic statement of the conservation of energy of a system is the *
14.Which of the following alloys does not have copper as one of the constituents? *
15.Who is authorized to nominate an individual to the Board of Electrical Engineering? *
injector condenser
boiler rejector
17.When sound wave is refracted from air to water, then which of the following will remain unchanged? *
Velocity Wavelength
Frequency None of these
18.Find the location of an image when the object is located 10.0 cm from a convex mirror. The mirror has a focal length of 10.0 cm. *
20.0 cm –5.00 cm
There will be no image at all. –20.0 cm
19.The force required to start a mass of 50 kg moving across a rough surface is 343 N. What is the coefficient of starting friction? *
0 1
0.80 0.70
20.A sample hormone, estradiol, C₁₈H₂₄O₂, contains 3.0 x 10²⁰ atoms of hydrogen. How many atoms of carbon does it contain? *
44 2.3 x 10²⁰
3.0 x 10²⁰ 18
21.Which one is the positively charged ion? *
Cathode Anion
Cation Anode
22.Five kg of water at 40 deg C is poured on a large block ice at 0 deg C. How much ice melts? *
1.8 kg 2.9 kg
2.5 kg 1.6 kg
23.What refers to the extinction of the debt by any satisfactory set of payments? *
24.Which wave requires a medium for transmission? *
light infrared
sound radio
25.An annuity where the payments are made at the beginning of each period. *
26.Find the change in internal energy of 5 lbm of oxygen gas when the temperature changes from 100°F to 120°F. cᵥ = 0.157
BTU/lbm-°R. *
27.You need a P40000 per year for four years to go to college. Your father invested P50000 in a 7% account for your education
when you were born. If you withdraw the P40000 at the end of your 17th, 18th, 19th, and 20th years, how much money will be left in
the account at the end of your 21st year? *
17000 16000
19000 18000
28.A ray of light strikes a polished surface at an angle of 37.0 degrees. Find the reflected angle of the light. *
29.Two cars having equal weights of 135 kN are traveling on a straight horizontal rack with velocities of 3 m/s to the right and 1.5
m/s to the left respectively. They collide and coupled during impact, determine their final common velocity? *
30.The external pressure applied to a confined fluid increases the pressure of every point in the fluid by an amount equal to the
external pressure. This is known as *
31.A convenience outlet circuit consisting of 8 outlets connected across a 220-V supply considering 180 W per outlet, what is the
maximum circuit current? *
6.54 A 8A
4.56 A None of these
32.According to kinetic theory of gases, the absolute zero temperature is attained when *
33.A piston cylinder contains 3 kg of air at 20°C and 300 kPa. It is now heated up in a constant pressure process to 600 K. Find the
final volume. *
34.In an isothermal process, the internal energy *
35.The amount of work of 0.60-kW electric drill can do in 1.0 min is *
36 J 0.6 J
36 kJ 0.6 kJ
36.Calculate the pH value of 8.0 M HCl. *
0.309 0.903
−0.903 −0.309
37.Determine the length of the shortest 2 mm diameter bronze wire which can be twisted through two complete turns without
exceeding a shearing stress of 70 MPa. Use G = 35 GPa. *
6280 mm 6380 mm
5640 mm 5460 mm
39.If Php 100,000 is invested at 12 percent interest, compounded monthly, the first year interest, is nearest to *
40.Conductors supplying a heating unit shall be calculated at _____ percent times the heating load plus the blower motor. *
115 100
130 125
41.A computer virus that infects the macros that are attached to documents and spreadsheets is called ________? *
42.Tenacity means *
43.This theory was popularized by Nicholaus Copernicus where he predicted that the sun is the center of the solar system. *
44.Underfloor raceways may be occupied up to _____ percent of the area. *
55 38
30 40
45.A pressure gage at elevation 6 m at the side of the tank with liquid reads 90 kPa. Another gage at elevation 4 m reads 110 kPa.
Compute the specific weight of the liquid. *
6 kN/m³ 12 kN/m³
8 kN/m³ 10 kN/m³
46.What is the chief ore of zinc? *
Sphalerite Limanite
Bauxite Cassiterite
47.What is the maximum font size you can apply for any character in Microsoft Word? *
1683 16038
1638 16380
48.Which of the following refers to the ratio of the unit lateral deformation to the unit longitudinal deformation? *
49.An RME may install electrical systems on systems in excess of 500 kVA or in excess of 600 volts provided
_____________________. (I) he is a holder of BSEE degree (II) he has more than 5 years of electrical installation experience (III)
he shall be under the supervision of a PEE or REE *
50.Determine the empirical formula of the compound with the following compositions by mass: C, 10.4%; S, 27.8%; Cl, 61.7%.
(Atomic Mass: C = 12.01 g/mole, S = 32.066 g/mole, Cl = 35.453 g/mole) *
CSCl₂ C₃S₂Cl
CSCl₆ CS₂Cl₃