Professional Documents
Culture Documents
: 1of
Problem Set No. 2 ME 522: Two Phase Flow and Heat Transfer
Problem 7
Predict the peak heat flux and minimum heat flux for pool boiling of water at atmospheric
results?
pressure. How do these predictions compare with experimental
Solution
yATE latm (Stm 1u)
a39.913 m p 229 lu
C0.51 m D.os31 P/
kS AMIN
MCtERTE >luN Np1t7 OnWs
Le
(158.19 0. s1 )
cnhard (193)
Problem8
In pool boiling, the predict the cirtical and minimum heat fluxes for R-12 at atmospheric
pressure. Plot the boiling curve.
Solution
from Astn trraty tads For hefrigan
py9,0 -172 ,81
.2
(145t+0.1sn a1
0,2 M
38,37 k a
Stuperhuw
0,141g hry0- )
O.144 (0,212uo )217, ) |0.0lgo3 n1, l- 0.2124o M,
0.2100 /,3)
G3.85
At
9000 Phillipplnes
Submisslon Date
AUgust 6, 2022
ME 522:Two Phase Flow and Heat Transfer Page No.: 4 of
ProblemSet No.
Problem 10
In a ball-bearing factory, steel balls of 1Ommdiameterat 1200 "Care quenched in a saturated vapor
at I atm. What is the initial total heat transfer rate trom each ball? What is the burn-out heat flux?
Solution
as a Sphut
2S.
hp225 2 225 o
0,T
LrerTas2e HO-Gsr °.
Cr,2.2 . 029.4 Jig.V,
0. 08SG
m-.
nle Casp) correu an rnbe berldn 3 uhn
Cdu 0, =
(er splhere)
iRP 6(-E to.t, Ctt) 0.25
tar)
(0.es
Sua) (0, 251)(PaA H1-01M1)
L2rO']+0,4(2054.1)(20D-1o) (l-ta)
4te12o -
R)
0.15(2ur9o (o,o)4.91)(0,2rH1(ar-0250
124930 M
2 ar
he 198,47K l , t-2so)
2
0.r757S
Problem 11
In a shell and tube heat exchanger, Freon 12 is used in a shell side to cool the fluids in the tubes.
The tubes are horizontal with an outside diameter of 1Smm. What is the maxinmum possible heat
flux assuming that the Freon is almost stagnant and at saturation temperature of 2 bars? It is
determined that the onsct of the nucleate boiling is at a wall temperature of 5 "C above the
saturation temperature. Calculate the heat flux and the heat transfer coefficient for a wall
temperature of 10 C above the saturation temperature of Freon.
Solution
e r . for. hofin tu (fm Cen 5Gaaje
teat tmns 0.25
L (Tar-t)
1 D,o4 hr 90( 14
S42. 2 ANs
lb/s. The
Problem12
ID pipe at a rate of 1
through a 0.5 inch, of
liquid oxygen passes is initiated at a wall temperature
In a cryogenic equipment is 100 psia and boiling
the end of the heated pipe
pressure at sub-cooling at this point.
210'R. Calculate the heat flux and liquid
Solution
T
Prr
F
lo.cr
ee D-019 (0.1S7) 3 (o.vol2y))"*/-347 (0.0vdtl27)Y
0,01 , DOd\27%
430.% hm®19 pr,
70 far Va
(8 . 44
((3. 44 e 0.082
. 0ow6S3
0.001s 4.feces4s (0.09 r 0.0G7
(84.4
3e73 824 1
Problem 13
a 12.7 mm ID tube. The water
flow rate is
Water at a pressure of 1.186 bar is to be evaporated in
difference for steam qualities
136 kg/hr. Prepare a table of values of heat flux against temperature
of 1, 5 and 20 percent by weight using Chen's correlation.
Solution
ha2ur2, a1 k
(0.012t)2
US
. (2 u
A 24S12l l k
21, re1.6
45a. 10kg|(10,43)
tD.o92(.179)
-0.01)/0.042
O.ot 4y.10/
0.a9
0, 9
Pe=/6 ll-Y) D /245.22 (l-0.01)(t. o24)
0.24yto Pa-
L.
y ErO,2
0.25 0 , ol
2(0-) C) (18.2n ) 2333. 4.
cmdahm is h he thng
|Sna Chen Bat z
=
Pr
;
hc>0,01 ()"CPraD keu)
he 0,073 (o1.32) 0.9 (1.683) O.t(-e30). 4 , s
0, O114
ln Prsurt dop
S (t
l2s3ro(30,32)7 1y
(t (2,57 KO
Problem 13
Water at a pressure of1.186 bar is to be evaporated in a 12.7 mm ID tube. The water flow rate is
136 kg/hr. Prepare a table of values ol heat flux against temperature difference for steam qualities
of 1,5 and 20 percent by weight using Chen's correlation.
Solution
wry0-00122 s(D1 (OVa) 0 1 C O.4s
D,4
0.001a(017(1" (2983 4u A.111 2u. 1
74 mV
M
Ctp to M
(-0.40) +0.a2 (o.180)
b C ) . 249.22(l-0. 0(,0127
170, 3
PezeDe Fa
Y -0,b5)0,H/0.120.0,2Hx(oa0.
0.o5
4.10
Problem 13
a 12.7 mm D tube. The water flow rate is
pressure of
1.186 bar is to be evaporated in
Water at a
against temperature difference for steam qualities
136 kg/hr. Prepare a table of values
of
heat fluxcorrelation.
Chen's
1,5 and 20 percent by weight using
of
Solution 0 0 0,071 0. 004
d
h
hc D, 025(Peza) *Przd 0.0(9924, n)l.639) 0.6
(S81 1212
0,4
urg 00122 S(DT)2(p°.7 Crr
(25OQpen A0,9,
(snA)
o.4S
0.9012n (o Au)(0)*"(to.33)
0 0X3 0.7XOa2 (z4Te"
(0.a12) V2
(U.
(s91.12(t (u 9ott.57.
hc th z
Solution
Y-0.o(u1.)
0.117
0,8
6 1 - 2 ) 1 /2a3.7L nl (-0[0,0124) (91.61
2S.
24 teF
de -02)0.412k /0,2H"g
D.0
0.20 Y.AS.
0.202
2lo,U3t l
Fe 21s70.u3t 4.05)
2e 12 /HG9(8%) 20412 Par nelent
O.014 O094 0,90 4 44
(o,012 m) (7.354 l )
h O-029 (re (Pr )
D.ve (2ueun.2) ( l s )."0.6sb - ) Y¢%. 535
Problem 13
in 12.7 mm ID tube. The water flow rate is
Water at a pressure of 1.186 bar is to be cvaporated temperature difference
a
for steam qualities
36 kg/hr. Prepare a table of values of heat flux against
of 1.5 and 20 percent by weight using Chen's correlation
Solution
0,11 1 , 0,4
,21p 2
( KlOh /22cul, 2)
0,4
(0.tt0uY() /2531.b).0,45 S uU a4 O4
| 0vot72
0.0S81 S02H1)471 274s]1¢
25%.02_
h h hw
-G24.8S+2628.D2 P1M4. SS. MK
bon19 u846SV
Solution
ngS1.
(7.
Er13 7.37
1917, hn257%.b2 F 13 HYt ST
-0.0r24
the kas3 i e 2eynold ' u b
R al leus h diTatl Mc lambur em
Corlaon (uhenr
Dorete l4nuinar Maw, DrAus - l e
ryinal or Meifics) MGhpahyle
h Py. F, +s
-
0f Southern Phlippines
Archutecture
instructor Leonei Pabilena
Rating:
College of Engineering and
USTP Lapasan, agayan de Oro Uty
Submisslon Date
9000 Philippines Augst 2022
Problem Set No. 2 ME 522: Two Phase Flow and
Heat Traiisfer Page No.:9 of
Problem 14
In problem 13, as a lirst approximation, one might choose to calculate the heat transfer coefficient
based on single phase (liquid) convection correlations. Estimate the error in heat flux predictions
for ihis approximaion.
Solution
x:1y.
,199
4 D Ds E Pr D 0, os (1w iS)(l.G&9)(0,0177n)
Ctp)Hod thenually devcleph
yh - . + 0 ,06S|)eel-
le,04 ) LuP
@x-.
9.tt0.DGs (0.or)(toau, As)(1.67) .S3
h.51
h 5.55%( D./30M w
21t:72 A"K
, 0124 M
Problem 14
in problem 13, as a first approximation, one might choose to calculate the heat transfer coellicient
bascd on single phase (liquid) convection correlations. Estimate the error in heat flux predictions
for tus appionnaion.
Solution
h ps(o. s)
@yeo.
h 244. 5u.
S.et 0.0us/D.012){1 )(1.19)
3IS( 0, 4 30
h
134, SB1
Problem 14
one might choose to calculate the heat transfer
coefficient
Inproblem 13, as a first approximation, correlations. Estimate the error in heat flux predictions
based on single phase (liquid) convection
for this approximatio.
Solution
h he +h g
oo 2 . bes .
301. 7-
Problem 15
Repeat problem 13 using the Shah's correlation and compare the predictions with Chen's.
Solution M #17,
co.o: :
10. 34 K0.6%0
0-0,01
Sah sapa hot
Mr (18) hut atto stats Hat O CA1)
h
.043
.8
hnh
.o3.1
oar 4)/)
Lq(D.029)/203, ) 1.68"/.90 = /T3
D.012
0.8/0,o2a 0.21
0.bs