Professional Documents
Culture Documents
com
Legal:
The content of this guide may not be sold, modified, or distributed in anyway without the expressed
written consent of the publisher. Reprinting, copying, or any other form of distribution for commercial
or non-commercial purposes is strictly prohibited and will be prosecuted.
Disclaimer:
Every attempt has been made to provide the most accurate information as possible. However, the
publisher accepts no liability for any wrong information as a result of purchasing and / or reading this
guide.
You can follow this guide at your own risk the publisher accepts no responsibility for any injury to any
person.
Copyright © www.Construct101.com
ISBN-13:
ISBN-10:
Material List
1 – 2×4 – 8′ D – 2 – 2×4 – 2′ 9″
G – 4 – 1×6 – 4′
G – 1 – 1×4 – 4′
H – 8 – 1×6 – 2′
I – 4 – 1×6 – 7″
J – 2 – 1×6 – 5′
K – 3 – 1/2 dowel – 4″
Cut two 1×4’s to 5″ long (A). Cut four 1×4’s to 1′ 10 1/2″ long (B). Pre-drill holes and assemble as shown
on illustration above using 1 1/4″ deck screws.
Cut two 1×4’s to 4′ long (C). Cut two 1×4’s to 1′ 10 1/2″ long (B). Pre-drill holes and assemble as shown
above using 1 1/4″ deck screws.
Cut the front and back legs and assemble as shown above.
Cut two 2×4’s to 2′ 9″ long (D). Pre-drill holes and screw 1 1/4″ deck screws through (C) and into (D). Cut
two 2×4’s to 5′ long (E). Pre-drill holes and screw 1 1/4″ deck screws through (C) and into (E).
Cut four 1×4’s to 2′ long (F). Pre-drill holes and assemble as shown above using 1 1/4″ deck screws.
Cut four 1×6’s and one 1×4 to 4′ long (G). Pre-drill holes and assemble as shown on illustration above
using 1 1/4″ deck screws.
Cut eight 1×6’s to 2′ long (H). Gap the boards (H) out evenly, pre-drill and assemble as shown on
illustration above using 1 1/4″ deck screws.
Cut two 1×6’s to 5′ long (J). Pre-drill holes and install the shelves as shown on illustration above using 1
1/4″ deck screws. Drill holes and install 1/2 dowels (K).