Professional Documents
Culture Documents
Specifier Notes: This product guide specification is written according to the Construction Specifications Institute (CSI)
3-Part Format, including MasterFormat, SectionFormat, and PageFormat, as described in The Project Resource
Manual—CSI Manual of Practice, Fifth Edition.
This section must be carefully reviewed and edited by the Architect or Engineer to meet the requirements of the
project and local building code. Coordinate this section with other specification sections and the Drawings. Delete all
“Specifier Notes” after editing this section.
SECTION 05 05 13
FACTORY APPLIED COATINGS FOR METAL
Specifier Notes: Delete any information below in Parts 1, 2 or 3 which is not required or relevant for the project.
PART 1 – GENERAL
1.01 SUMMARY
A. This section includes various plating finishes for use on critical electrical components.
1.02 REFERENCES
A. Federal Specifications
1. QQ-N-290 Federal Specification Nickel Plating (Electrodeposited)
2. QQ-Z-325 Federal Specification Zinc Coating (Electrodeposited)
3. QQ-S-365 Federal Specification Silver Plating (Electrodeposited): General
Requirements for
B. Military Specifications
1. MIL-T-10727 Military Specification Tin Plating, Electrodeposited or Hot-Dipped, For
Ferrous and Nonferrous Metals
2. MIL-C-14550 Military Specification Copper Plating (Electrodeposited)
3. MIL-C-26074 Military Specification Coating, Electroless Nickel, Requirements For
1.03 SUBMITTALS
B. Submit manufacturer’s descriptive literature and product specifications for each product.
1.05 WARRANTY
PART 2 – PRODUCTS
2.01 GENERAL
A. The following high quality plating finishes shall be available for use on critical electrical components:
1. Silver
2. Tin
3. Copper
4. Copper Acid
5. Watt Nickel
6. Electroless Nickel
7. Zinc
2.02 MANUFACTURERS
A. Acceptable Manufacturers:
Thomas & Betts Corporation
8155 T&B Blvd
Memphis, TN 38125
800-816-7809, 901-252-5000
www.tnb.com
2.03 FINISHES
PART 3 – EXECUTION
Not Used
END OF SECTION