to install the Door Upper Hinge Kit components onto a Staples Kiosk.
KIT CONTENTS PROCEDURE
ITEM DESCRIPTION QTY Check off each step as it is completed: 1 Instructions 1 _____1. Remove the bottom Door Hinge Pin, 2 Screws 4 then remove the front door from the 3 Washers (not shown below) 4 kiosk. 4 Support Plate 1 5 Drill Bit, Small 1 _____2. Remove the old hinge (if it did not fall 6 Drill Bit, Large 1 out already).
_____3. Locate and record the Date Stamp on
the inside of the Door. The metal stability plate must be temporarily removed to access the Date Stamp. Reinstall the metal stability plate after accessing the Date Stamp. Stamp Location Stamp Location (under plate) (plate removed)
Date Stamp
NOTE: E-mail the Date Stamp information
to CAS@xerox.com (Include “DOOR DATE STAMP as the e-mail subject)
TITLE DWG. DWG. SHEET
INSTALLATION INSTRUCTIONS: SIZE NO. 702PXXXXX REV. DOOR UPPER HINGE KIT LTR SHEET 1 OF 2 A
Form 56312 REV3 (4/95)
____ 4. Using the small drill bit, drill a hole in _____6. Insert the Support Plate through the the center of the plastic boss from the holes that were drilled out. The holes inside of the door. may need to be enlarged slightly to line up with the metal frame on the inside of the door.
Outside View Inside View
____ 5. Using the large drill bit, drill out the
holes that were made in the previous step. Only drill out the plastic. DO NOT drill into the metal frame on _____7. Use the supplied Washers and Screws the inside of the door. to attach the Support Plate to the door.
_____8. Reinstall the Door and check for fit.
_____9. Send the Date Stamp information to
CAS@Xerox.com. Include “DOOR DATE STAMP” as the e-mail subject.
TITLE DWG. DWG. SHEET
INSTALLATION INSTRUCTIONS: SIZE NO. 702PXXXXX REV. DOOR UPPER HINGE KIT LTR SHEET 2 OF 2 A